According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 2023 Buick Envision has 1 documented issue, with 1 rated critical. The most serious is Fuel Pump Control Module Failure Causing Stalling and Intermittent No-Start (Gen2 LSY) ($500-$1,400 repair). Across all issues with published estimates, repair costs range from $500 to $1,400. DIY maintenance guides at au7o.io.
On the 2021-2023 Buick Envision LSY 2.0L Turbo, second-generation Envisions have a repeating NHTSA pattern of the fuel pump control module failing, producing an engine that dies without warning while driving and a crank-no-start afterward, or that only fires on 7-8 of every 10 attempts. Owners report no warning lights and no stored codes in several cases. One especially dangerous report describes the vehicle stalling in a center freeway lane where the electronic shifter would not allow neutral with the engine off, stranding the car in traffic. Failures are documented from about 11,000 miles, and replacement modules have been back-ordered for extended periods.
Common Symptoms
Engine dies while driving with no warning
Cranks but will not start, intermittently
No check engine light or stored trouble codes at the time of failure
Vehicle stalls and cannot be shifted to neutral to be pushed
How to Fix
Check fuel pressure and fuel pump power/enable at the module before replacing the pump assembly. The repair is replacement of the fuel pump control module (typically mounted at the rear of the vehicle) followed by module programming. Check GM's open recall and field-action list against your VIN, and verify the vehicle's shift-to-neutral procedure with the engine off so you can move it if it strands you.
EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Campaign #22V90300008/12/2022
AIR BAGS:SRS MALFUNCTION WARNING LAMP/LIGHT
General Motors, LLC (GM) is recalling certain 2021 Buick Envision, Cadillac CT4, CT5, Escalade, Escalade ESV, Chevrolet Tahoe, Corvette, Suburban, GMC Yukon, Yukon XL vehicles. The communications gateway module incorrectly processes a loss of communication with the sensing diagnostic module (SDM), causing the air bag malfunction indicator light to inconsistently illuminate.
Campaign #21V42100010/06/2021
Enter your VIN at NHTSA.gov to check recalls specific to your vehicle.
🔧
A mechanic who knows YOUR exact car
Answers tuned to your year, make, model & trim — not generic advice. Save your garage so it always has the right context.
Get ahead of Buick Envision problems — free
Leave your email and we'll alert you the moment there's a new recall or known issue for your Buick Envision. Free, no account needed.
According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 2023 Buick Envision has 1 documented issue. The documented issue is: Fuel Pump Control Module Failure Causing Stalling and Intermittent No-Start (Gen2 LSY). Of these, 1 is rated critical and should be addressed promptly.
Is the Buick Envision reliable?
The 2023 Buick Envision has 1 known issue compiled from NHTSA recalls, manufacturer TSBs, and owner forum reports. 1 issue is rated critical: Fuel Pump Control Module Failure Causing Stalling and Intermittent No-Start (Gen2 LSY). Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common Buick Envision problems?
Repair costs for known Buick Envision issues range from $500 to $1,400, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Fuel Pump Control Module Failure Causing Stalling and Intermittent No-Start (Gen2 LSY), typically costs $500-$1,400 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 2021-2023 Buick Envision Fuel Pump Control Module Failure Causing Stalling and Intermittent No-Start (Gen2 LSY)?
Second-generation Envisions have a repeating NHTSA pattern of the fuel pump control module failing, producing an engine that dies without warning while driving and a crank-no-start afterward, or that only fires on 7-8 of every 10 attempts. Owners report no warning lights and no s… Repairs typically run $500-$1,400. Severity: high.
Content on this page was compiled with AI assistance using NHTSA complaints, TSBs, owner reports, and public automotive data. While we strive for accuracy, this information may contain errors. Always verify repair procedures and specifications with your vehicle's service manual or a qualified mechanic.
