According to Au7o's analysis of 400+ owner reports, the 2023 BMW iX has 17 documented known issues, with 7 rated critical. The most serious are iX ADCAM False-Warning and Sensor-Limit Diagnosis, 2022-2024 iX Propulsion-Loss Recall 25V-395, Driver's Frontal Airbag May Fail to Deploy - Recall 23V-079 and Long Parts Backorders ($0-$0 repair), Combined Charging Unit Assembly Defect Causes Power Interruption While Driving - Recall 23V-449 ($0-$5,000 repair), Electric Steering Rack Failure - 'Changed Steering Effort' Warning with Groaning Noise ($0-$4,500 repair), Battery Cell Monitoring Circuit (CSC) Loose Connections Cause Sudden Stall - Recall 23V-295 ($0-$2,500 repair) and High-Voltage Battery Cell Module Assembly Defect - Recall 25V-470 Frame Stress, Drive Power Loss and Fire Risk ($0-$8,000 repair). The most commonly reported issue is DC Fast Charging Speed Inconsistency with 240 owner reports. Across all issues with published estimates, repair costs range from $150 to $8,000.
BMW of North America, LLC (BMW) is recalling certain 2022-2025 IX, 2023-2024 I7, and 2022-2023 i4 vehicles. The high-voltage battery cell modules may not have been assembled properly, resulting in stress on the module frame and possible module failure.
BMW of North America, LLC (BMW) is recalling certain 2022-2024 iX xDrive50 and 2023 i4 eDrive35, i4 eDrive40, and i4 M50 Hybrid Electric vehicles. The high voltage battery cell monitoring circuit may have improperly secured electrical connections which can result in an engine stall.
Campaign #23V29500026/04/2023
VEHICLE SPEED CONTROL:CRUISE CONTROL
BMW of North America, LLC (BMW) is recalling certain 2022-2024 iX xDrive50 and iX M60 vehicles. The driver may unintentionally reactivate the cruise control system while turning the steering wheel at low speeds, resulting in a sudden increase of vehicle speed.
Campaign #23V409000
🔧
A mechanic who knows YOUR exact car
Answers tuned to your year, make, model & trim — not generic advice. Save your garage so it always has the right context.
Get ahead of BMW iX problems — free
Leave your email and we'll alert you the moment there's a new recall or known issue for your BMW iX. Free, no account needed.
According to Au7o's analysis of 400+ owner reports, the 2023 BMW iX has 17 documented issues. The most frequently reported are: iX ADCAM False-Warning and Sensor-Limit Diagnosis, 2022-2024 iX Propulsion-Loss Recall 25V-395, Driver's Frontal Airbag May Fail to Deploy - Recall 23V-079 and Long Parts Backorders. Of these, 7 are rated critical and should be addressed promptly.
Is the BMW iX reliable?
The 2023 BMW iX has 17 known issues documented across 400+ owner reports. 7 issues are rated critical: iX ADCAM False-Warning and Sensor-Limit Diagnosis and 2022-2024 iX Propulsion-Loss Recall 25V-395 and Driver's Frontal Airbag May Fail to Deploy - Recall 23V-079 and Long Parts Backorders and Combined Charging Unit Assembly Defect Causes Power Interruption While Driving - Recall 23V-449 and Electric Steering Rack Failure - 'Changed Steering Effort' Warning with Groaning Noise and Battery Cell Monitoring Circuit (CSC) Loose Connections Cause Sudden Stall - Recall 23V-295 and High-Voltage Battery Cell Module Assembly Defect - Recall 25V-470 Frame Stress, Drive Power Loss and Fire Risk. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common BMW iX problems?
Repair costs for known BMW iX issues range from $0 to $8,000, depending on the specific problem and whether you choose DIY or professional repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 2022-2024 BMW iX iX ADCAM False-Warning and Sensor-Limit Diagnosis?
BMW SIB 66 05 23 defines an I20 iX path for camera-based assistance complaints including deactivation, missed road signs and excessively frequent Check Control messages 930 or 2260. BMW identifies environmental visibility limits, windshield/camera installation, non-approved tires… Severity: high.
What is the 2022-2024 BMW iX 2022-2024 iX Propulsion-Loss Recall 25V-395?
BMW recall 25V-395 covers 25,447 VIN-defined 2022-2024 iX vehicles produced February 4, 2021 through January 16, 2024. Electric-drive-motor software can mistakenly identify a double-isolation condition and shut down the high-voltage system about 15-20 seconds after a red warning,… Severity: high.
Content on this page was compiled with AI assistance using NHTSA complaints, TSBs, owner reports, and public automotive data. While we strive for accuracy, this information may contain errors. Always verify repair procedures and specifications with your vehicle's service manual or a qualified mechanic.
Filter:
On the 2022-2023 BMW iX, nHTSA campaign 23V449000 recalls BMW iX, i4 and i7 vehicles whose Combined Charging Unit was not manufactured correctly, leaving internal components improperly connected or assembled. The important distinction for iX owners is the failure mode: this campaign is not about AC charging refusing to work, it is about the CCU interrupting electrical power while the vehicle is in motion. NHTSA records the consequence as an improperly assembled CCU that 'can interrupt power and cause engine stall, increasing the risk of a crash.' On the iX the CCU is the combined on-board charger and DC/DC converter, so a fault there simultaneously threatens both traction power and the 12V supply that runs steering assist, brake assist and lighting. This is consistent with the 2023 iX complaint file, which contains multiple reports of losing propulsion and, in the worst cases, of losing power-assisted steering and braking together at speed - one complainant describing that they 'lost power assisted steering AND power assisted braking. I had to decelerate with no power brakes.' The remedy is replacement of the CCU, not a software update.
Common Symptoms
How to Fix
Check your VIN against campaign 23V449000; the remedy is free replacement of the Combined Charging Unit by a BMW dealer. Because a CCU fault can take out both traction power and 12V accessory supply, do not defer this recall and do not treat a single unexplained power interruption as a one-off - have the dealer pull the CCU and EME fault memory for DC/DC converter and internal-communication entries. If the car has ever dropped both power steering and power brake assist at the same time, report it to NHTSA as well as to the dealer, since that combination is the signature of a supply-side rather than drivetrain fault. Out of warranty, CCU replacement on the iX typically runs $2,500-$5,000 including programming; under recall it is free.
On the 2022-2023 BMW iX, nHTSA campaign 23V295000 recalls BMW iX xDrive50 (and certain i4) vehicles whose high-voltage battery cell monitoring circuit - the CSC board that measures individual cell voltages and temperatures and reports them to the battery management controller - was built with electrical connections that were not properly secured. When a monitoring connection intermittently opens, the battery management system loses valid cell data and, because it cannot verify pack safety, commands an immediate protective shutdown of the high-voltage system. NHTSA records the consequence bluntly as 'An engine stall increases the risk of a crash.' On the iX this presents as the drive system dropping out with no throttle response while rolling, usually with a red drivetrain warning, and it can occur at any speed. It is often confused with the 25V-395 drive-motor software campaign because the symptom is identical, but 23V-295 is a hardware defect in the pack's sensing harness and cannot be resolved by a software update. The failure tends to be intermittent early on - a single unexplained shutdown that clears on a restart - before becoming repeatable.
Common Symptoms
How to Fix
Verify VIN eligibility for campaign 23V295000; the remedy is free replacement of the high-voltage battery cell monitoring circuit at a BMW dealer. If your iX has had one or more unexplained drive-power dropouts and the recall shows as already performed, have the dealer read the battery management fault memory for cell-voltage-implausibility and communication-loss entries against the CSC boards before accepting a 'no fault found' result - the connections are intermittent and often will not fault on a static test. Do not let a dealer sell you a full high-voltage battery pack for this symptom without first confirming the CSC circuit has been checked. Out of warranty, CSC monitoring circuit replacement typically runs $900-$2,500 in parts and labor because the pack must be opened; under recall or the 8-year/100,000-mile HV warranty it is free.
On the 2022-2025 BMW iX, nHTSA recall campaign 25V470000 covers 2022-2025 BMW iX (along with 2023-2024 i7 and 2022-2023 i4) in which high-voltage battery cell modules were not properly assembled at the cell-module level. The improper assembly puts mechanical stress on the module frame, and that stress can progress to module failure. This is distinct from the earlier 22V-541 internal-short recall and from the 25V-395 drive-motor software campaign: 25V-470 is a physical module build defect, and the remedy is hardware replacement of specific modules rather than a software flash. NHTSA states the consequence as: 'Battery module failure may lead to a shutdown of the high-voltage system which can result in a loss of drive power, increasing the risk of a crash. In addition, module failure increases the risk of a fire.' Owners typically experience it as an abrupt 'Drivetrain malfunction' or complete high-voltage shutdown with the car coasting to a stop, often preceded by no warning at all. Initial owner notification went out September 11, 2025, with a second notice expected once parts became available - meaning many iX owners sat for months with an open, unrepairable safety recall. Because module supply is constrained, dealers diagnose the specific failing module by SOC/voltage-deviation logging rather than replacing the entire pack.
Common Symptoms
How to Fix
Check your VIN at NHTSA.gov or with BMW (1-800-525-7417) against campaign 25V470000. The remedy is free replacement of the specific affected high-voltage battery cell modules by a BMW dealer - not a software update, so an OTA will not close this recall. If the vehicle throws a high-voltage shutdown or 'Drivetrain malfunction / Drive not possible' message, stop driving and have it flatbedded rather than attempting to restart, since module failure carries a stated fire risk. Ask the dealer to pull the battery management SOC-deviation log; that log identifies which module is out of tolerance and is what BMW uses to authorize module-level rather than whole-pack replacement. Out of warranty, individual module replacement runs roughly $3,000-$8,000 depending on module position and labor to drop the pack; a full pack is far more. Under the 8-year/100,000-mile federal HV battery warranty and under the recall, the repair is free.
On the 2022-2026 BMW iX, the BMW iX can experience inconsistent DC fast charging speeds, sometimes charging far below the advertised 195-200 kW peak rate. Issues include the car limiting charge speed due to battery temperature, communication errors with CCS chargers, and software bugs that cap charging at lower rates even when conditions are optimal.
Common Symptoms
Charging speed below 100 kW at fast charger
Charging session fails to start
Charging stops prematurely
Battery not pre-conditioning for fast charge
Charging speed drops rapidly after starting
Error message on charger screen
How to Fix
Pre-condition the battery using navigation to a DC fast charger (the car will warm the battery en route). Ensure the latest software is installed — BMW has released multiple charging optimization updates. Try different charging networks if one consistently underperforms. Some hardware issues require dealer diagnosis of the onboard charger.
High Confidence240 owner reportsLast reported by owners Mar 2026Reviewed Mar 2026
On the 2022-2024 BMW iX, bMW SIB 61 06 24 defines an I20 iX path for charging complaints where the charger, infrastructure, authentication, vehicle settings, connector condition, temperature or the vehicle may be responsible. BMW requires the customer complaint and charging conditions to be documented before assigning a vehicle fault. The bulletin does not support a universal iX DC-fast-charge defect or fixed charging-speed threshold.
Common Symptoms
Charging does not start or is interrupted
Charging power is lower than expected
Complaint changes with charger, station, authentication or settings
How to Fix
Document where and how the failure occurred, displayed messages, charger type, authentication method and vehicle charge settings. Test another charger, outlet, adapter or public station, inspect the plug/socket, and run BMW ISTA charging tests before condemning the vehicle. Only after the vehicle works at the dealer and fails at the customer location should infrastructure be treated as likely. Exact 2022 iX ShowMeTheParts data contains no charging category or candidate, so no retail link is approved.
On the 2022-2025 BMW iX, the BMW iX uses a 60Ah AGM 12V battery that powers all vehicle electronics. Owners report the vehicle dying after several days of parking with the 12V battery completely dead while the main HV battery retains charge. The iX has components that cause phantom drain regardless of settings because the vehicle must always be ready to power on, and the 12V battery may last only 2 years in some cases. Software bugs can prevent proper sleep mode, keeping modules active and draining the 12V. The iDrive 8 system not entering sleep mode is a documented cause. Failed or stuck TCB (telematics) modules attempting constant cellular reconnection also contribute to drain. The DC-DC converter should maintain 12V charge from the HV battery during normal operation, so persistent drain indicates a software or hardware fault.
Exterior lamps staying on after car is locked (sleep mode failure)
Key fob won't unlock vehicle (12V too low for receivers)
Multiple system errors cascade on startup after 12V recovery
How to Fix
First ensure latest software is installed - BMW has released OTA updates addressing sleep mode bugs. If 12V battery has been deeply discharged, it may be permanently damaged and need replacement. Use a BMW-approved battery tender for vehicles parked for extended periods. Dealer can perform a sleep current test to identify which module is preventing proper shutdown. If CCU (Central Charging Unit) is malfunctioning, it may need replacement under warranty. For battery replacement, part number for 60Ah AGM may include 01405A38CB9. Must be registered to IBS via BimmerLink or dealer ISTA.
What you need to fix it
Only diagnosis- and fitment-reviewed repair parts are linked here.
Genuine BMW 60-Ah AGM battery 61217604802
Cross-ref61217604802
Confirmed failed iX 12-volt battery replacement. Confirm VIN, production data and the required BMW battery-registration procedure before ordering..
Medium ConfidenceVerifiedLast reported by owners Feb 2026Reviewed Aug 2026
On the 2022-2026 BMW iX, bMW SIB 65 28 25 defines an I20 iX path with Head Unit 4, 5 or 6 for an intermittent or permanent Multifunction Display black screen, including a missing navigation display. BMW identifies unfavorable head-unit software. This does not support the frozen card's broad hardware, wiring, battery-voltage or all-screen replacement assumptions.
Common Symptoms
Intermittent Multifunction Display black screen
Permanent Multifunction Display black screen
Head-unit function such as navigation is not displayed
How to Fix
Confirm the installed head-unit generation and current I-level. With the vehicle stationary, follow the bulletin sequence: full sleep cycle, a volume-control head-unit reset longer than 70 seconds, the BMW-directed 12-volt reset when necessary, then ISTA display test plan ABL-DIT-AT6581_CID3. Program the complete vehicle only through the BMW path and do not replace the display before the required tests.
On the 2022-2025 BMW iX, the BMW iX's iDrive 8 infotainment system experiences random crashes, screen blanking, and system reboots while driving. The curved display goes completely blank for 15-45 seconds during reboot cycles, disabling navigation, climate controls, audio, backup camera, and safety displays simultaneously. Some owners report the system entering a continuous reboot loop requiring dealer intervention. Phone integration (wireless CarPlay/Android Auto) is frequently cited as a trigger for crashes. The system may also fail to enter sleep mode properly after parking, causing background processes to drain the 12V battery. HUD settings, instrument cluster preferences, and audio settings may reset after each crash. BMW has released multiple OTA software updates to address stability, with version .63 and later resolving many issues. Early 2022 production vehicles are most affected. Per ixforums.com, one owner reported the screen going blank 3 times in 5 days.
Infotainment screen goes completely blank while driving
System enters continuous reboot loop
Screen flickering with camera feed glitches after reboot
Apple CarPlay/Android Auto disconnects randomly
HUD and cluster settings reset after system crash
Climate controls become inaccessible during screen blank
Phone Bluetooth pairing profiles overwrite each other
Backup camera unavailable after system restart
Main screen stuck on BMW logo, won't load interface
How to Fix
Install latest iDrive software via OTA update (Settings > Software Update). Version .63+ resolved many stability issues. For immediate fix: Soft reset by holding volume/power button for 10+ seconds. For persistent crashes: Dealer can force-flash the head unit using ISTA. Some owners report improved stability by using wired CarPlay/Android Auto instead of wireless. Factory reset (Settings > General > Reset) can resolve persistent software corruption. If screen enters continuous reboot loop, dealer must perform head unit hardware inspection - may need MGU (main head unit) replacement.
Medium ConfidenceLast reported by owners Feb 2026Reviewed Feb 2026
On the 2022-2023 BMW iX, nHTSA campaign 22V483000 recalls 2022-2023 BMW iX and i4 vehicles for a head unit software defect in which the Central Information Display may fail to show critical safety information while the car is in Valet Parking Mode. On the iX this is more consequential than the campaign title suggests, because the iX has no conventional instrument binnacle redundancy for many alerts - a substantial amount of state-of-charge, drivetrain, tyre pressure and warning-lamp information is presented through the curved display. NHTSA records the consequence as missing warnings and indicator lights increasing crash risk. Owners typically never notice the defect because Valet Parking Mode is rarely used, which is precisely why this campaign has a low completion rate relative to BMW's other iX software recalls, and it lingers as an open item that surfaces during a pre-purchase VIN check on used 2022-2023 iX cars. The remedy is a free head unit software update and is often bundled with the HU-H4/H5 infotainment updates the car needs anyway.
Common Symptoms
How to Fix
Check your VIN against campaign 22V483000; the remedy is a free display head unit software update at a BMW dealer. Because this campaign is easy to overlook, run a NHTSA VIN check before buying any used 2022-2023 iX and treat an open 22V-483 as a sign the car has missed other software campaigns too - ask the dealer to run a full campaign check and flash the head unit to the current release in the same visit. Avoid using Valet Parking Mode until the update is applied, since safety warnings may not be displayed while it is active. An over-the-air update alone does not necessarily close this campaign; confirm in BMW's system that it shows as performed. No owner cost.
On the 2022-2024 BMW iX, bMW SIB 66 05 23 defines an I20 iX path for camera-based assistance complaints including deactivation, missed road signs and excessively frequent Check Control messages 930 or 2260. BMW identifies environmental visibility limits, windshield/camera installation, non-approved tires and chassis changes as possible boundaries. The bulletin does not establish model-wide phantom braking or prove a failed radar sensor.
ADCAM assistance deactivates or cannot be activated
Check Control message 930 or 2260 appears excessively
Fault 7E0197 for short-term sensor blindness
Fault 7E00A0 after windshield replacement or incomplete calibration
How to Fix
Read ADCAM fault memory with ISTA before replacing anything. Inspect and clean the windshield camera area, verify wiper performance and camera-holder installation, and document weather, light, traffic and road conditions. If fault 7E00A0 follows windshield replacement, start the required camera calibration in ISTA. If no fault or installation problem exists, explain the owner-manual operating limits; BMW states parts replacement does not correct environmental system limitations.
On the 2022-2023 BMW iX, nHTSA campaign 23V079000 recalls BMW iX (and X1) vehicles in which the driver's front airbag may have been manufactured incorrectly and can fail to deploy in a crash. NHTSA records the consequence as a non-deploying airbag increasing driver injury risk. What elevates this beyond a routine airbag campaign for iX owners is the repair-availability problem documented in the vehicle's own complaint record: the 2023 iX complaint file contains fifteen or more airbag-related complaints, and the dominant theme in them is not the defect itself but months-long waits for replacement parts, with owners left driving a vehicle under an open airbag recall. At least one complainant reported a crash in which 'none of the airbags deployed during the impact.' The recall is separate from campaign 22V240000, which addresses a software defect where the airbag malfunction indicator light may fail to illuminate on 2022-2023 iX - meaning an affected car can carry both a defective airbag and a warning lamp that will not tell you about it.
Common Symptoms
How to Fix
Check your VIN against both campaign 23V079000 (driver's airbag replacement) and 22V240000 (airbag control unit software reprogramming) - they are separate campaigns and closing one does not close the other. The remedy for 23V-079 is free replacement of the driver's frontal airbag. If your dealer reports no parts available, ask them to place a VIN-specific parts order with a documented case number through BMW of North America rather than an open backorder, and ask about a loaner or rental at BMW's expense, which BMW has provided in some airbag recall cases where the wait extends past a few weeks. Do not accept the airbag warning lamp being off as evidence the system is fine until 22V-240 is confirmed performed. No owner cost for either campaign.
On the 2022-2023 BMW iX, nHTSA campaign 23V409000 recalls BMW iX xDrive50 and iX M60 vehicles for a control-logic defect in which the driver can unintentionally reactivate cruise control while turning the steering wheel at low speeds. The stalk-mounted cruise resume input can be triggered by the driver's hand during a steering input, and because the iX's electric drivetrain delivers torque instantly, reactivation produces an immediate and unexpected acceleration rather than the gradual build a combustion car would give. NHTSA states the consequence as 'A sudden increase in vehicle speed can increase the risk of a crash.' This matters specifically because low-speed turning is exactly the parking-lot and junction context where an unexpected surge is least recoverable, and it is a plausible mechanical explanation for a subset of the unintended-acceleration complaints in the iX file - the 2022 iX complaint set includes reports of the vehicle lunging forward without driver input, and the 2023 file contains eight or more sudden-acceleration incidents including collisions. The remedy is a vehicle software update, so it is cheap and fast but easy for owners to skip.
Common Symptoms
How to Fix
Check your VIN against campaign 23V409000 - the remedy is a free BMW dealer software update, so there is no reason to defer it. Until it is done, be aware that a resume input on the cruise stalk during a steering maneuver can re-engage the set speed; keep your hand position clear of the left stalk when maneuvering at low speed. If your iX has surged unexpectedly, note whether the cruise control indicator illuminated at the moment of the surge - that distinguishes this defect from a genuine drivetrain fault and is the detail a dealer needs. Verify after the visit that the software update was actually flashed and the campaign closed in BMW's system, since software campaigns are frequently bundled with other work and occasionally missed. No owner cost under recall.
On the 2022-2024 BMW iX, bMW recall 25V-395 covers 25,447 VIN-defined 2022-2024 iX vehicles produced February 4, 2021 through January 16, 2024. Electric-drive-motor software can mistakenly identify a double-isolation condition and shut down the high-voltage system about 15-20 seconds after a red warning, causing loss of propulsion. Power-assisted steering and braking remain available.
High-voltage shutdown and loss of propulsion about 15-20 seconds later
How to Fix
Check the VIN for an open 25V-395 campaign. If included, install BMW's free electric-drive-motor software update through the authorized dealer or approved recall over-the-air process. Do not order a battery ECU, motor or battery part from this card. Capture any red warning and arrange diagnosis if the VIN is not included or the fault remains after the recall remedy.
On the 2022-2023 BMW iX, iX owners report a 'Steering effort has changed' / 'Changed steering effort' message in the instrument cluster, frequently accompanied by a groaning or moaning noise from the front of the car and noticeably heavier steering, progressing in some cases to complete loss of power assistance. This is not a recall item and not the i5/i7 steering-spindle campaign - it is a failure of the iX's electromechanical steering rack itself, and BMW's fix has consistently been full steering rack replacement rather than a software calibration. NHTSA's 2022 iX complaint file shows steering as the single largest theme, with six of twenty-nine complaints citing intermittent changed-steering-effort warnings and rack failures, including one owner reporting 'steering greatly reduced. The power steering was completely gone.' What makes this financially serious is the mileage pattern: complainants report failures between roughly 10,000 and 21,000 miles, and several report the failure landing just outside the 4-year/50,000-mile new vehicle warranty. The warning is often intermittent for days or weeks before assist is lost, and the vehicle remains drivable during that window but with unpredictably variable effort.
Common Symptoms
How to Fix
Treat the first 'Changed steering effort' message as a failing rack, not a glitch - document it with the dealer immediately while the car is still in warranty, because an undocumented intermittent warning is what leaves owners paying for the rack later. Have the dealer read the EPS control unit fault memory for motor-position-sensor and torque-sensor implausibility entries and record the mileage at first occurrence. A groaning or moaning noise from the front end that tracks steering input confirms the rack rather than a software fault; do not accept a steering-angle-sensor recalibration as the fix if the noise is present. The vehicle is drivable but should be serviced promptly since assist can drop out entirely. Out of warranty, iX steering rack replacement including programming typically runs $2,800-$4,500 at a BMW dealer. Ask BMW of North America for goodwill assistance if the first warning is documented inside warranty.
On the 2022-2025 BMW iX, the BMW iX xDrive50 and M60 are equipped with 2-axle adaptive air suspension that can experience compressor failures, air spring leaks, and air line cracks. The air compressor can fail from overwork (running excessively to compensate for small leaks), producing loud operating noises before failure. Air springs develop rubber cracks from UV exposure and temperature cycling, causing slow leaks that become apparent overnight when the vehicle drops to one side. Cracked air lines from vibration fatigue are also reported. The air suspension warning light illuminates when the system can no longer maintain proper ride height. Compressor failures are reported as early as 20,000-30,000 miles on some 2022-2023 models. The xDrive40 uses conventional steel springs and is not affected. Dealer diagnosis is typically required as the system has multiple possible failure points.
Common Symptoms
Vehicle sitting low on one corner or one axle
Air suspension warning light on dashboard
Loud buzzing or grinding from compressor (under rear cargo area)
Compressor running continuously (audible after car is turned off)
"Suspension malfunction" or "Ride height control" error message
Harsh ride quality (system defaulting to fail-safe height)
How to Fix
Diagnosis required to identify failing component. Common repairs: Air compressor replacement ($600-1,200 parts + labor). Individual air spring replacement ($800-1,500 per corner). Air line repair/replacement ($100-500). Full system reset after any component replacement. Air springs typically last 50,000-70,000 miles; compressors can last 100,000+ miles if no leaks cause overwork. Check for air leaks using soapy water on air lines and spring connections. Dealer warranty covers air suspension for 4 years/50,000 miles. Some owners have had claims approved under BMW goodwill beyond warranty.
Medium ConfidenceLast reported by owners Feb 2026Reviewed Feb 2026
Community reported
160 owners
On the 2022-2026 BMW iX, the iX with optional air suspension can develop calibration errors that cause the car to sit at incorrect ride heights or display suspension fault warnings. The ride height sensors can drift out of calibration, particularly after tire changes, wheel alignment, or battery disconnection. The system may also fail to properly adjust between driving modes.
Common Symptoms
Car sits unevenly
Suspension warning light
Ride height doesn't change with mode selection
Car too low or too high
Warning after tire change
Suspension fault after battery disconnect
Comfort mode feels stiff
How to Fix
A suspension calibration reset via ISTA at the dealer resolves most cases. This involves driving the car through a specific calibration routine. If ride height sensors are faulty, they must be replaced. After any wheel or tire service, a calibration check is recommended.
Medium Confidence160 owner reportsLast reported by owners Mar 2026Reviewed Mar 2026
On the 2022-2025 BMW iX, the BMW iX has received complaints about body panel fitment and overall build quality, particularly on early 2022 production vehicles. Reported issues include uneven panel gaps, trim pieces that pop out or rattle, interior squeaks and rattles, and in extreme cases, body panels detaching (one owner reported the rear bumper detaching in rain). Some owners report needing 9+ dealership visits in 17 months for various "niggly little" quality issues. The iX is manufactured at BMW's Dingolfing plant in Germany, and quality appears to have improved with later production dates. Consumer Reports rated the 2023 iX below average for reliability. These issues are cosmetic and don't affect safety or drivability but are disappointing given the $80,000-110,000 price range.
Common Symptoms
Visible uneven panel gaps between body panels
Interior trim pieces popping out or not seated properly
Rattles or squeaks from dashboard, doors, or rear cargo area
Wind noise at highway speeds from poorly sealed body panels
Trim alignment issues visible on close inspection
Rear bumper or panel fitment issues
How to Fix
Most panel gap and trim issues can be addressed under BMW's 4 year/50,000 mile warranty at no cost. Document all issues with photos and bring to dealer service. For rattles, dealer can install additional insulation or tighten trim clips. For panel gap issues, body panel adjustment at dealer (covered under warranty). For persistent quality issues affecting enjoyment, document everything for potential BMW goodwill claim or lemon law consideration if the number of dealer visits is excessive. Some owners have negotiated buybacks on severely affected vehicles.
BMW of North America, LLC (BMW) is recalling certain 2022-2025 i4, 2022-2024 IX, 2023-2024 I7, and 2024 I5 vehicles. The electric drive motor software may shut down the high-voltage system, causing a loss of drive power.
Campaign #25V39500023/07/2025
AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE:SOFTWARE
BMW of North America, LLC (BMW) is recalling certain 2022-2023 iX xDrive40, iX XDrive50, and iX M60 vehicles. The air bag malfunction indicator light and display message may not illuminate in the event of a problem with the air bag control or pedestrian protection systems, due to incorrect software.
What is the 2022-2023 BMW iX Driver's Frontal Airbag May Fail to Deploy - Recall 23V-079 and Long Parts Backorders?
NHTSA campaign 23V079000 recalls BMW iX (and X1) vehicles in which the driver's front airbag may have been manufactured incorrectly and can fail to deploy in a crash. NHTSA records the consequence as a non-deploying airbag increasing driver injury risk. What elevates this beyond… Repairs typically run $0-$0. Severity: high.
What is the 2022-2023 BMW iX Combined Charging Unit Assembly Defect Causes Power Interruption While Driving - Recall 23V-449?
NHTSA campaign 23V449000 recalls BMW iX, i4 and i7 vehicles whose Combined Charging Unit was not manufactured correctly, leaving internal components improperly connected or assembled. The important distinction for iX owners is the failure mode: this campaign is not about AC charg… Repairs typically run $0-$5,000. Severity: high.
What is the 2022-2023 BMW iX Electric Steering Rack Failure - 'Changed Steering Effort' Warning with Groaning Noise?
iX owners report a 'Steering effort has changed' / 'Changed steering effort' message in the instrument cluster, frequently accompanied by a groaning or moaning noise from the front of the car and noticeably heavier steering, progressing in some cases to complete loss of power ass… Repairs typically run $0-$4,500. Severity: high.
What is the 2022-2023 BMW iX Battery Cell Monitoring Circuit (CSC) Loose Connections Cause Sudden Stall - Recall 23V-295?
NHTSA campaign 23V295000 recalls BMW iX xDrive50 (and certain i4) vehicles whose high-voltage battery cell monitoring circuit - the CSC board that measures individual cell voltages and temperatures and reports them to the battery management controller - was built with electrical… Repairs typically run $0-$2,500. Severity: high.
What is the 2022-2025 BMW iX High-Voltage Battery Cell Module Assembly Defect - Recall 25V-470 Frame Stress, Drive Power Loss and Fire Risk?
NHTSA recall campaign 25V470000 covers 2022-2025 BMW iX (along with 2023-2024 i7 and 2022-2023 i4) in which high-voltage battery cell modules were not properly assembled at the cell-module level. The improper assembly puts mechanical stress on the module frame, and that stress ca… Repairs typically run $0-$8,000. Severity: high.
What is the 2022-2026 BMW iX DC Fast Charging Speed Inconsistency?
The BMW iX can experience inconsistent DC fast charging speeds, sometimes charging far below the advertised 195-200 kW peak rate. Issues include the car limiting charge speed due to battery temperature, communication errors with CCS chargers, and software bugs that cap charging a… Repairs typically run $0-$2,000. Severity: medium.
What is the 2022-2024 BMW iX iX Charger/Infrastructure-First Charging Diagnosis?
BMW SIB 61 06 24 defines an I20 iX path for charging complaints where the charger, infrastructure, authentication, vehicle settings, connector condition, temperature or the vehicle may be responsible. BMW requires the customer complaint and charging conditions to be documented be… Severity: medium.
What is the 2022-2025 BMW iX 12V Auxiliary Battery Drain - Sleep Mode & Module Wake Issues?
The BMW iX uses a 60Ah AGM 12V battery that powers all vehicle electronics. Owners report the vehicle dying after several days of parking with the 12V battery completely dead while the main HV battery retains charge. The iX has components that cause phantom drain regardless of se… Repairs typically run $0-$800. Severity: medium.
What is the 2022-2025 BMW iX Air Suspension Compressor & Air Spring Failures - xDrive50/M60?
The BMW iX xDrive50 and M60 are equipped with 2-axle adaptive air suspension that can experience compressor failures, air spring leaks, and air line cracks. The air compressor can fail from overwork (running excessively to compensate for small leaks), producing loud operating noi… Repairs typically run $600-$4,000. Severity: medium.
What is the 2022-2026 BMW iX iX HU-H4/H5/H6 Multifunction Black-Screen Path?
BMW SIB 65 28 25 defines an I20 iX path with Head Unit 4, 5 or 6 for an intermittent or permanent Multifunction Display black screen, including a missing navigation display. BMW identifies unfavorable head-unit software. This does not support the frozen card's broad hardware, wir… Severity: medium.
What is the 2022-2025 BMW iX iDrive 8 System Crashes, Reboots & Screen Blank?
The BMW iX's iDrive 8 infotainment system experiences random crashes, screen blanking, and system reboots while driving. The curved display goes completely blank for 15-45 seconds during reboot cycles, disabling navigation, climate controls, audio, backup camera, and safety displ… Repairs typically run $0-$2,000. Severity: medium.
What is the 2022-2023 BMW iX Cruise Control Unintentionally Reactivates While Turning at Low Speed - Recall 23V-409?
NHTSA campaign 23V409000 recalls BMW iX xDrive50 and iX M60 vehicles for a control-logic defect in which the driver can unintentionally reactivate cruise control while turning the steering wheel at low speeds. The stalk-mounted cruise resume input can be triggered by the driver's… Repairs typically run $0-$0. Severity: medium.
What is the 2022-2026 BMW iX Air Suspension Calibration Errors?
The iX with optional air suspension can develop calibration errors that cause the car to sit at incorrect ride heights or display suspension fault warnings. The ride height sensors can drift out of calibration, particularly after tire changes, wheel alignment, or battery disconne… Repairs typically run $150-$1,200. Severity: low.
What is the 2022-2025 BMW iX Panel Gaps & Build Quality Issues?
The BMW iX has received complaints about body panel fitment and overall build quality, particularly on early 2022 production vehicles. Reported issues include uneven panel gaps, trim pieces that pop out or rattle, interior squeaks and rattles, and in extreme cases, body panels de… Repairs typically run $0-$500. Severity: low.
What is the 2022-2023 BMW iX Central Information Display Hides Safety Information in Valet Parking Mode - Recall 22V-483?
NHTSA campaign 22V483000 recalls 2022-2023 BMW iX and i4 vehicles for a head unit software defect in which the Central Information Display may fail to show critical safety information while the car is in Valet Parking Mode. On the iX this is more consequential than the campaign t… Repairs typically run $0-$0. Severity: low.
