According to Au7o's analysis of 560+ owner reports, the 2014 Ford E-Series has 5 documented known issues. No issues are rated critical, indicating generally reliable ownership. The most commonly reported issue is Front Door Hinge Pin Wear and Door Sagging with 300 owner reports. Across all issues with published estimates, repair costs range from $20 to $4,000. DIY maintenance guides at au7o.io.
On the 1992-2016 Ford E-Series, econoline bodies trap water in the rocker panel, the lower cargo/side door openings, the wheel arches and - most seriously - the rear crossmember just ahead of the step bumper, behind the swing-out rear doors. Salt-belt vans rot from the inside out: the rocker perforates below the sliding or hinged side door and the rear crossmember can rot away almost completely, which is a structural concern because the rear door latch and bumper mount to that area. Because these bodies stayed in production essentially unchanged from 1992 to 2014 (and continue as cutaways), the same panels rust across the whole span.
Common Symptoms
Bubbling paint and perforation along the rocker panel
Rust holes at the wheel arch lips
Rotted crossmember ahead of the step bumper
Rear doors sagging or not latching squarely
Water leaking into the cargo area
How to Fix
Probe the rocker seams, the wheel-arch lips and the rear crossmember with a pick before buying or before an inspection. Repair is cut-and-weld with reproduction rocker, wheel arch and cargo-door repair panels (available in full 5-piece kits and in cargo-door-specific versions), backed by internal cavity wax; slip-on cover panels bonded and riveted over rot are a common but short-lived shortcut. Structural crossmember rot at the rear must be welded, not patched. No corrosion recall covers this.
On the 2003-2014 Ford E-Series, e-Series cargo and passenger vans suffer from severe front door hinge pin wear, especially on the driver side due to frequency of use. The hinge pins and bushings wear to the point where the door sags noticeably, making it difficult to close and causing the door to strike the fender. Commercial and fleet vans experience this much faster due to high door cycle counts. The heavy steel doors accelerate wear on the cast hinge brackets.
Common Symptoms
Driver door sags when opened
Door difficult to close or latch — requires lifting while closing
Popping or grinding noise when opening or closing door
Door contacts fender or rocker panel
Gap between door and body uneven (wider at bottom)
How to Fix
Replace door hinge pins and bushings using a hinge pin repair kit. Dorman 38474 is the standard repair kit. If the hinge bracket itself is worn (egg-shaped holes), the hinge must be replaced entirely. Use a door support jack when removing old hinges to prevent door from falling. Grease new pins with white lithium grease during installation.
Low Confidence300 owner reportsLast reported by owners Mar 2026Reviewed Mar 2026
Community reported
260 owners
On the 2000-2014 Ford E-Series, e-Series vans use rubber transmission cooler hose sections that connect the steel lines to the radiator-mounted transmission cooler. These rubber sections harden, crack, and leak transmission fluid. The leak is often slow enough that the fluid level drops gradually, causing the transmission to slip before the leak is noticed. The rubber hoses are routed near the exhaust manifold where heat accelerates degradation.
Replace the rubber transmission cooler line sections with silicone or braided stainless steel upgraded hoses. Use quality hose clamps rated for transmission fluid pressure. Check fluid level after repair and top off with Mercon V (or Mercon LV for 2009+). Install an auxiliary external transmission cooler if the van is used for towing.
Low Confidence260 owner reportsLast reported by owners Mar 2026Reviewed Mar 2026
On the 2000-2014 Ford E-Series, vans equipped with rear A/C suffer from refrigerant leaks in the rear evaporator core or the long refrigerant lines running under the body. Corrosion from road salt accelerates line deterioration.
Common Symptoms
Rear A/C blows warm
Front A/C works but rear does not
Refrigerant low frequently
Hissing sound from rear
How to Fix
Locate the leak with UV dye and an electronic leak detector. Replace corroded lines or the rear evaporator core. Consider upgrading to barrier-style hoses for longer life.
On the 1997-2019 Ford E-Series, the modular Triton gasoline engines fitted to the E-Series - 4.6L V8, 5.4L V8 and 6.8L V10, all 2-valve in this van (the E-Series never received the 3-valve heads used in F-Series trucks) - break their exhaust manifold studs where they thread into the aluminium head. Repeated heat cycling plus road salt corrodes and fatigues the factory studs, usually the front-most one on each bank. The result is the classic 'Triton tick' that is loudest on cold start and quiets as the manifold expands, and it is frequently misdiagnosed as a lifter or an exhaust leak at the gasket.
Common Symptoms
Ticking or puffing noise loudest on cold start
Exhaust smell in the cabin
Tick quiets as engine warms
Soot staining around the manifold flange
Failed emissions test from an upstream leak
How to Fix
Locate the leak by feel or with a smoke test, then remove the manifold and extract the broken studs - usually by welding a nut to the exposed stump or by drilling and using an extractor, with the head in place. Ford supplies an updated stainless stud, P/N W703902-S403, with nut W701706-S2; the manifold gasket must be replaced at the same time and the studs torqued to 71-115 in-lb with the nuts at 204-239 in-lb. No recall exists; it is a wear repair.
According to Au7o's analysis of 560+ owner reports, the 2014 Ford E-Series has 5 documented issues. The most frequently reported are: Transmission Cooler Line Rubber Hose Degradation and Leak, Rear A/C Evaporator and Line Leaks, Rocker Panel, Wheel Arch and Rear Body Crossmember Rust-Through. None are rated critical, but regular maintenance is recommended.
Is the Ford E-Series reliable?
The 2014 Ford E-Series has 5 known issues documented across 560+ owner reports. No issues are rated critical, suggesting generally good reliability. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common Ford E-Series problems?
Repair costs for known Ford E-Series issues range from $20 to $4,000, depending on the specific problem and whether you choose DIY or professional repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 2000-2014 Ford E-Series Transmission Cooler Line Rubber Hose Degradation and Leak?
E-Series vans use rubber transmission cooler hose sections that connect the steel lines to the radiator-mounted transmission cooler. These rubber sections harden, crack, and leak transmission fluid. The leak is often slow enough that the fluid level drops gradually, causing the t… Repairs typically run $50-$400. Severity: medium.
What is the 2000-2014 Ford E-Series Rear A/C Evaporator and Line Leaks?
Vans equipped with rear A/C suffer from refrigerant leaks in the rear evaporator core or the long refrigerant lines running under the body. Corrosion from road salt accelerates line deterioration. Repairs typically run $400-$1,200. Severity: medium.
What is the 1992-2016 Ford E-Series Rocker Panel, Wheel Arch and Rear Body Crossmember Rust-Through?
Econoline bodies trap water in the rocker panel, the lower cargo/side door openings, the wheel arches and - most seriously - the rear crossmember just ahead of the step bumper, behind the swing-out rear doors. Salt-belt vans rot from the inside out: the rocker perforates below th… Repairs typically run $600-$4,000. Severity: medium.
What is the 1997-2019 Ford E-Series Triton 2-Valve Exhaust Manifold Stud Breakage and Exhaust Tick?
The modular Triton gasoline engines fitted to the E-Series - 4.6L V8, 5.4L V8 and 6.8L V10, all 2-valve in this van (the E-Series never received the 3-valve heads used in F-Series trucks) - break their exhaust manifold studs where they thread into the aluminium head. Repeated hea… Repairs typically run $400-$1,600. Severity: medium.
What is the 2003-2014 Ford E-Series Front Door Hinge Pin Wear and Door Sagging?
E-Series cargo and passenger vans suffer from severe front door hinge pin wear, especially on the driver side due to frequency of use. The hinge pins and bushings wear to the point where the door sags noticeably, making it difficult to close and causing the door to strike the fen… Repairs typically run $20-$300. Severity: low.
Content on this page was compiled with AI assistance using NHTSA complaints, TSBs, owner reports, and public automotive data. While we strive for accuracy, this information may contain errors. Always verify repair procedures and specifications with your vehicle's service manual or a qualified mechanic.
