What is the 1990-1998 Mitsubishi Eclipse AWD Transfer Case Lockup and Output Shaft Seal Leaks (GSX, NHTSA Recall 98V069001)?

On AWD GSX (and Talon TSi AWD platform) cars, the transfer case output shaft seal leaks gear oil until the case runs dry, and per NHTSA recall 98V069001 'lockup of the transfer case can occur due to insufficient lubrication.' Owners have reported the wheels locking at 50-68 mph,… Repairs typically run $300-$2,000. Severity: high.

What is the 1990-1998 Mitsubishi Eclipse AWD (GSX) Transfer Case Lockup - NHTSA Recall 98V069000?

The all-wheel-drive Eclipse GSX was recalled (NHTSA campaign 98V069, March 1998) covering 1990-1998 GSX models. A brass plug in the center of the transfer case yoke can leak, causing insufficient lubrication in the transfer case; the transfer case can then lock up, which can caus… Repairs typically run $800-$2,500. Severity: high.

What is the 1990-1999 Mitsubishi Eclipse Front Subframe / Crossmember and Rocker Rust Corrosion (salt-belt cars)?

Like most DSM-era cars, 1990s Eclipses in road-salt regions suffer structural corrosion of the front crossmember/subframe (which locates the lower control arms) as well as the rocker panels, strut towers, and rear subframe/trailing-arm mounts. Because the lower control arms bolt… Repairs typically run $500-$2,500. Severity: high.

What is the 1990-1999 Mitsubishi Eclipse Timing Belt Failure on Interference 4G63 (catastrophic valve damage)?

The DOHC 4G63 (both the naturally aspirated 4G63 and turbo 4G63T across 1990-1999) is an interference engine: if the timing belt snaps or jumps, the pistons strike the open valves, bending valves and often damaging the head and pistons. These belts were specified for replacement… Repairs typically run $600-$3,500. Severity: high.

What is the 1990-1999 Mitsubishi Eclipse Rust at Rear Wheel Arches, Lower Quarter Panels, and Rockers?

Both 1G and 2G Eclipse/Talon bodies rot in predictable places: the rear wheel arches and the lower quarter panel just ahead of the rear tires, the rocker/support area under the doors, and — most structurally serious — the front strut towers. The arch and rocker seams trap road sa… Repairs typically run $500-$3,000. Severity: medium.

What is the 1990-1994 Mitsubishi Eclipse 1G ECU Electrolytic Capacitor Leakage (Rough Idle, No-Start)?

The electrolytic capacitors in 1990-1994 ECUs have defective seals and leak electrolyte onto the circuit board, corroding traces and surface-mount components — 1990-1993 units are worst, and the front capacitor in 1990 ECUs is known to short and burn through the board under it, t… Repairs typically run $50-$300. Severity: medium.

What is the 1990-1999 Mitsubishi Eclipse Cam Angle Sensor (CAS) / Optical Distributor Failure - No-Start and Stalling?

The 4G63 uses a cam angle sensor (an optical sensor mounted in the distributor housing on the exhaust cam) to provide the crank/cam timing signal to the ECU. With age the CAS optical disc, LEDs/phototransistors, and internal bearing wear out and produce erratic or lost signals. O… Repairs typically run $200-$550. Severity: medium.

What is the 1990-1999 Mitsubishi Eclipse Lifter Tick from Hydraulic Lash Adjusters?

The 4G63's hydraulic lash adjusters (lifters) are notorious for clogging with oil varnish or bleeding down, producing the infamous DSM 'lifter tick' from the valve cover. The early-design lifters used in 1G cars were revised twice by Mitsubishi specifically to address the noise. Repairs typically run $150-$900. Severity: low.

What is the 1990-1999 Mitsubishi Eclipse Valve Stem Seals Hardening - Oil Consumption and Blue Smoke at Idle?

As the 4G63/4G63T ages, the valve stem seals harden and shrink, letting oil seep down the valve guides into the combustion chamber. The signature symptom is a puff of blue smoke on startup or on a quick rev after the engine has idled for a while, plus gradual oil consumption. Tur… Repairs typically run $400-$1,200. Severity: low.

Mitsubishi · Known Issues

1993 Mitsubishi Eclipse Problems: 10 Issues Every Owner Should Know

1993 model year · NHTSA recalls, manufacturer TSBs, and owner forum reports · Updated July 2026

Share:@au7o.io

According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 1993 Mitsubishi Eclipse has 10 documented known issues, with 5 rated critical. The most serious are Balance Shaft Belt Failure Destroying the Timing Belt (Interference 4G63) ($1,500-$4,000 repair), AWD Transfer Case Lockup and Output Shaft Seal Leaks (GSX, NHTSA Recall 98V069001) ($300-$2,000 repair), AWD (GSX) Transfer Case Lockup - NHTSA Recall 98V069000 ($800-$2,500 repair), Front Subframe / Crossmember and Rocker Rust Corrosion (salt-belt cars) ($500-$2,500 repair) and Timing Belt Failure on Interference 4G63 (catastrophic valve damage) ($600-$3,500 repair). Across all issues with published estimates, repair costs range from $50 to $4,000. DIY maintenance guides at au7o.io.

Frequently Asked Questions

What are the most common Mitsubishi Eclipse problems?

According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 1993 Mitsubishi Eclipse has 10 documented issues. The most frequently reported are: Balance Shaft Belt Failure Destroying the Timing Belt (Interference 4G63), AWD Transfer Case Lockup and Output Shaft Seal Leaks (GSX, NHTSA Recall 98V069001), AWD (GSX) Transfer Case Lockup - NHTSA Recall 98V069000. Of these, 5 are rated critical and should be addressed promptly.

Is the Mitsubishi Eclipse reliable?

The 1993 Mitsubishi Eclipse has 10 known issues compiled from NHTSA recalls, manufacturer TSBs, and owner forum reports. 5 issues are rated critical: Balance Shaft Belt Failure Destroying the Timing Belt (Interference 4G63) and AWD Transfer Case Lockup and Output Shaft Seal Leaks (GSX, NHTSA Recall 98V069001) and AWD (GSX) Transfer Case Lockup - NHTSA Recall 98V069000 and Front Subframe / Crossmember and Rocker Rust Corrosion (salt-belt cars) and Timing Belt Failure on Interference 4G63 (catastrophic valve damage). Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Mitsubishi Eclipse problems?

Repair costs for known Mitsubishi Eclipse issues range from $50 to $4,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Balance Shaft Belt Failure Destroying the Timing Belt (Interference 4G63), typically costs $1,500-$4,000 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 1990-1999 Mitsubishi Eclipse Balance Shaft Belt Failure Destroying the Timing Belt (Interference 4G63)?

The turbo 4G63 is an interference engine, and its narrow balance shaft belt runs directly alongside the main timing belt. When the aging balance shaft belt frays or snaps — common on neglected 1G six-bolt and 2G seven-bolt cars — the debris gets caught in the timing belt, causing… Repairs typically run $1,500-$4,000. Severity: high.

All 10 Known Issues

Other Mitsubishi Models

Frequently Asked Questions

What are the most common Mitsubishi Eclipse problems?

Is the Mitsubishi Eclipse reliable?

How much does it cost to fix common Mitsubishi Eclipse problems?

What is the 1990-1999 Mitsubishi Eclipse Balance Shaft Belt Failure Destroying the Timing Belt (Interference 4G63)?

1990-1999 Mitsubishi Eclipse: Balance Shaft Belt Failure Destroying the Timing Belt (Interference 4G63)#

1990-1999 Mitsubishi Eclipse: Timing Belt Failure on Interference 4G63 (catastrophic valve damage)#

1990-1999 Mitsubishi Eclipse: Lifter Tick from Hydraulic Lash Adjusters#

1990-1999 Mitsubishi Eclipse: Valve Stem Seals Hardening - Oil Consumption and Blue Smoke at Idle#

1990-1998 Mitsubishi Eclipse: AWD Transfer Case Lockup and Output Shaft Seal Leaks (GSX, NHTSA Recall 98V069001)#

1990-1998 Mitsubishi Eclipse: AWD (GSX) Transfer Case Lockup - NHTSA Recall 98V069000#

1990-1999 Mitsubishi Eclipse: Front Subframe / Crossmember and Rocker Rust Corrosion (salt-belt cars)#

1990-1999 Mitsubishi Eclipse: Rust at Rear Wheel Arches, Lower Quarter Panels, and Rockers#

1990-1994 Mitsubishi Eclipse: 1G ECU Electrolytic Capacitor Leakage (Rough Idle, No-Start)#

1990-1999 Mitsubishi Eclipse: Cam Angle Sensor (CAS) / Optical Distributor Failure - No-Start and Stalling#