What is the 2017-2025 Audi RS3 2.5T Five-Cylinder Carbon Buildup?

The RS3 2.5T direct-injected engine develops heavy carbon buildup on all five intake valves. The high-performance tune and boost levels create more crankcase vapors, accelerating deposit formation. Repairs typically run $500-$1,000. Severity: medium.

What is the 2015-2019 Audi RS3 2015-2018 / Certain 2019 RS3 Magnetic-Ride Rear Shock Noise - TSB 2059240/1?

Audi TSB 2059240/1 applies to RS3 vehicles equipped with Audi magnetic ride when knocking or rattling is heard from the rear over uneven roads and diagnosis confirms the rear shock absorbers. Its scope is 2015-2018 vehicles and 2019 vehicles only within VIN sequence 000001-906967… Severity: medium.

What is the 2015-2023 Audi RS3 Severe Carbon Buildup on Intake Valves (2.5T 5-Cylinder)?

The 2.5T EA855 5-cylinder engine in the RS3 and TT RS (2015-2023) suffers from severe carbon buildup on intake valves due to direct injection. Fuel sprays directly into the combustion chamber, bypassing intake valves which only receive oil vapors from the PCV system. These vapors… Repairs typically run $800-$1,500. Severity: medium.

What is the 2017-2020 Audi RS3 Front Brake Rotor Judder and Pad-Deposit "Warping" on the 8V RS3 — Steering Shimmy Under Braking?

Front brake judder is the single most repeated complaint from 8V RS3 owners. Threads on Audizine and the Official Audi RS3 Owners Club describe a steering-wheel shimmy and brake-pedal pulsation appearing as early as 5,000 to 12,000 miles on stock front rotors and pads. Audi revis… Repairs typically run $900-$1,800. Severity: medium.

What is the 2015-2021 Audi RS3 Haldex AWD Pump and Filter Screen Clogging on the 8V RS3 — Rear Drive Drops Out?

The 8V RS3 sends drive rearward through a Haldex-type electro-hydraulic coupling on the rear differential. Its weak point is not the gearset but the electric pump and the fine mesh filter screen ahead of it. Clutch debris and metallic wear particles progressively clog the screen;… Repairs typically run $300-$3,500. Severity: medium.

Audi · Known Issues

2019 Audi RS3 Problems: 11 Known Issues

2019 model year · 171+ owner reports · Updated September 2026

Share:@au7o.io

According to Au7o's analysis of 171+ owner reports, the 2019 Audi RS3 has 11 documented known issues, with 6 rated critical. The most serious are Fuel Injector Failure and "Torch Effect" (2.5T) ($1,500-$25,000 repair), 2017-2020 / 2022-2023 RS3 Drive-System Warning or No-Start Diagnosis - TSB 2067757/3, Water Pump / Thermostat Housing Coolant Leak on 2.5 TFSI (DAZA/DNWA) — Failures as Early as 8,000 Miles ($900-$1,800 repair), DQ500 S tronic Mechatronic and Clutch-Pack Failure — Lost Gears, No Reverse, Limp Mode ($2,500-$8,000 repair), PODS Airbag Connector Loose Contact and Cable Chafing — Recall 19V474 (2017-2019 RS3) ($0-$0 repair) and Passenger Occupant Detection System Sensor Mat Failure — Passenger Airbag Switches Off (Recall 21V198 / Audi 69BY) ($0-$0 repair). The most commonly reported issue is 2.5T Five-Cylinder Carbon Buildup with 171 owner reports. Across all issues with published estimates, repair costs range from $300 to $25,000. DIY maintenance guides at au7o.io.

Frequently Asked Questions

What are the most common Audi RS3 problems?

According to Au7o's analysis of 171+ owner reports, the 2019 Audi RS3 has 11 documented issues. The most frequently reported are: Fuel Injector Failure and "Torch Effect" (2.5T), 2017-2020 / 2022-2023 RS3 Drive-System Warning or No-Start Diagnosis - TSB 2067757/3, Water Pump / Thermostat Housing Coolant Leak on 2.5 TFSI (DAZA/DNWA) — Failures as Early as 8,000 Miles. Of these, 6 are rated critical and should be addressed promptly.

Is the Audi RS3 reliable?

The 2019 Audi RS3 has 11 known issues documented across 171+ owner reports. 6 issues are rated critical: Fuel Injector Failure and "Torch Effect" (2.5T) and 2017-2020 / 2022-2023 RS3 Drive-System Warning or No-Start Diagnosis - TSB 2067757/3 and Water Pump / Thermostat Housing Coolant Leak on 2.5 TFSI (DAZA/DNWA) — Failures as Early as 8,000 Miles and DQ500 S tronic Mechatronic and Clutch-Pack Failure — Lost Gears, No Reverse, Limp Mode and PODS Airbag Connector Loose Contact and Cable Chafing — Recall 19V474 (2017-2019 RS3) and Passenger Occupant Detection System Sensor Mat Failure — Passenger Airbag Switches Off (Recall 21V198 / Audi 69BY). Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Audi RS3 problems?

Repair costs for known Audi RS3 issues range from $0 to $25,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Fuel Injector Failure and "Torch Effect" (2.5T), typically costs $1,500-$25,000 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 2015-2023 Audi RS3 Fuel Injector Failure and "Torch Effect" (2.5T)?

The 2.5T EA855 engine in RS3 and TT RS suffers from fuel injector failures that can cause catastrophic engine damage. Failed injectors create a "torch effect" where excessive fuel sprays into the cylinder, melting pistons and destroying the engine. This requires complete engine r… Repairs typically run $1,500-$25,000. Severity: high.

All 11 Known Issues

Other Audi Models

Frequently Asked Questions

What are the most common Audi RS3 problems?

Is the Audi RS3 reliable?

How much does it cost to fix common Audi RS3 problems?

What is the 2015-2023 Audi RS3 Fuel Injector Failure and "Torch Effect" (2.5T)?

When Issues Typically Appear

2015-2023 Audi RS3: Fuel Injector Failure and "Torch Effect" (2.5T)#

2017-2023 Audi RS3: 2017-2020 / 2022-2023 RS3 Drive-System Warning or No-Start Diagnosis - TSB 2067757/3#

2017-2025 Audi RS3: 2.5T Five-Cylinder Carbon Buildup#

2015-2023 Audi RS3: Severe Carbon Buildup on Intake Valves (2.5T 5-Cylinder)#

2017-2019 Audi RS3: PODS Airbag Connector Loose Contact and Cable Chafing — Recall 19V474 (2017-2019 RS3)#

2017-2020 Audi RS3: Passenger Occupant Detection System Sensor Mat Failure — Passenger Airbag Switches Off (Recall 21V198 / Audi 69BY)#

2017-2025 Audi RS3: Water Pump / Thermostat Housing Coolant Leak on 2.5 TFSI (DAZA/DNWA) — Failures as Early as 8,000 Miles#

2015-2025 Audi RS3: DQ500 S tronic Mechatronic and Clutch-Pack Failure — Lost Gears, No Reverse, Limp Mode#

2015-2019 Audi RS3: 2015-2018 / Certain 2019 RS3 Magnetic-Ride Rear Shock Noise - TSB 2059240/1#

2017-2020 Audi RS3: Front Brake Rotor Judder and Pad-Deposit "Warping" on the 8V RS3 — Steering Shimmy Under Braking#

2015-2021 Audi RS3: Haldex AWD Pump and Filter Screen Clogging on the 8V RS3 — Rear Drive Drops Out#

What is the 2017-2023 Audi RS3 2017-2020 / 2022-2023 RS3 Drive-System Warning or No-Start Diagnosis - TSB 2067757/3?

What is the 2017-2025 Audi RS3 Water Pump / Thermostat Housing Coolant Leak on 2.5 TFSI (DAZA/DNWA) — Failures as Early as 8,000 Miles?

What is the 2015-2025 Audi RS3 DQ500 S tronic Mechatronic and Clutch-Pack Failure — Lost Gears, No Reverse, Limp Mode?

What is the 2017-2019 Audi RS3 PODS Airbag Connector Loose Contact and Cable Chafing — Recall 19V474 (2017-2019 RS3)?

What is the 2017-2020 Audi RS3 Passenger Occupant Detection System Sensor Mat Failure — Passenger Airbag Switches Off (Recall 21V198 / Audi 69BY)?

What is the 2017-2025 Audi RS3 2.5T Five-Cylinder Carbon Buildup?

What is the 2015-2019 Audi RS3 2015-2018 / Certain 2019 RS3 Magnetic-Ride Rear Shock Noise - TSB 2059240/1?

What is the 2015-2023 Audi RS3 Severe Carbon Buildup on Intake Valves (2.5T 5-Cylinder)?

What is the 2017-2020 Audi RS3 Front Brake Rotor Judder and Pad-Deposit "Warping" on the 8V RS3 — Steering Shimmy Under Braking?

What is the 2015-2021 Audi RS3 Haldex AWD Pump and Filter Screen Clogging on the 8V RS3 — Rear Drive Drops Out?