What is the 2005-2010 Nissan Frontier Radiator SMOD - Strawberry Milkshake of Death (Transmission Cooler Failure)?

Nissan’s final warranty-extension notice applies to all 2005-2010 Frontier vehicles equipped with automatic transmissions. It states that an internal crack can develop in the radiator’s automatic-transmission oil-cooler tube, allowing engine coolant to leak internally and damage… Severity: high.

What is the 2005-2006 Nissan Frontier IPDM ECM Relay Defect on 2005-2006 Frontier (Safety Recall 10V517000)?

Nissan's 10V517000 recall reaches the 2005 and 2006 Frontier pickup. At issue is the ECM relay contained in the Frontier's Intelligent Power Distribution Module assembly. The relay's diode uses a silicon molding to reduce electrical current noise, but Nissan found the relay may a… Severity: high.

What is the 2005-2012 Nissan Frontier Timing Chain Rattle and Failure (QR25DE 4-Cylinder)?

The 4-cylinder QR25DE engine in the Frontier is prone to timing chain tensioner and guide failure, separate from the VQ40DE V6 issue. The primary timing chain tensioner loses pressure, allowing chain slack that causes a distinctive rattle on startup. If ignored, the chain can ski… Repairs typically run $800-$1,500. Severity: high.

What is the 2005-2019 Nissan Frontier RE5R05A 5-Speed Valve Body and Integrated TCM Solenoid Failure Causing Limp Mode?

The Jatco RE5R05A five-speed automatic used in the second-generation Frontier carries its transmission control module bolted directly to the valve body, submerged in hot ATF. That packaging is the weak point: sustained heat cycling and vibration crack solder joints and kill solen… Repairs typically run $900-$3,500. Severity: high.

What is the 2005-2019 Nissan Frontier Catalytic Converter Efficiency Failure (P0420 / P0430) on the 4.0L VQ40DE?

The 4.0L VQ40DE Frontier is a repeat offender for catalyst efficiency codes, typically appearing somewhere past 100,000 miles as P0420 (Bank 1) or P0430 (Bank 2), often both. The converter is usually a victim rather than the root cause: unburned fuel from a misfire, an over-rich… Repairs typically run $900-$2,600. Severity: medium.

What is the 2005-2025 Nissan Frontier Transfer Case Shift Actuator Motor and Position Switch Failure - 4WD Will Not Engage?

On 4x4 Frontiers the transfer case is shifted by an electric actuator motor with position switches rather than a mechanical lever, and both the motor and the switches are common failure points. The classic presentation is that the 4WD selector is turned and nothing happens: the d… Repairs typically run $350-$1,100. Severity: medium.

What is the 2005-2024 Nissan Frontier Wheel Speed Sensor Corrosion Triggering ABS, VDC OFF and SLIP Warning Lights?

The Frontier's wheel speed sensors sit exposed at the hubs and fail from corrosion, road salt and debris damage, and because the same signal feeds the anti-lock brakes, the Vehicle Dynamic Control stability system and the traction control, one dead sensor lights the whole cluster… Repairs typically run $150-$500. Severity: medium.

What is the 2005-2019 Nissan Frontier Fuel Sending Unit Failure and Inaccurate Gauge?

The Frontier fuel level sending unit is prone to failure, causing the fuel gauge to read inaccurately or erratically. The gauge may show full when the tank is half empty, drop suddenly from half to empty, or fluctuate randomly. This is caused by wear on the sending unit rheostat… Repairs typically run $200-$500. Severity: low.

What is the 2005-2021 Nissan Frontier Rear Differential Bushing Clunk?

The D40 Frontier develops a clunk from the rear end during acceleration and deceleration transitions, caused by worn rear differential mount bushings. The rubber bushings deteriorate over time, allowing the differential to shift and create a noticeable "clunk" when transitioning… Repairs typically run $30-$400. Severity: low.

What is the 2005-2021 Nissan Frontier Rear Leaf Spring Sag and Flat Bed Syndrome?

The D40 Frontier is known for progressive rear leaf spring sag, often called "flat bed syndrome." The factory leaf springs are relatively light-duty and sag over time, especially if the truck is used for hauling. The sagging rear end gives the truck a nose-up rake appearance and… Repairs typically run $150-$1,000. Severity: low.

What is the 2005-2021 Nissan Frontier HVAC Blend Door Actuator Failure Causing No Heat and Clicking Under the Dash?

The plastic-geared blend door actuators behind the Frontier dash strip their teeth or lose position calibration, and the failure is easy to recognize: a repeated clicking or ratcheting from under the dash or behind the glovebox each time the temperature is changed or the ignition… Repairs typically run $200-$900. Severity: low.

Nissan · Known Issues

2006 Nissan Frontier Problems: 14 Known Issues

2006 model year · 3,600+ owner reports · Updated September 2026

Share:@au7o.io

According to Au7o's analysis of 3,600+ owner reports, the 2006 Nissan Frontier has 14 documented known issues, with 7 rated critical. The most serious are Timing Chain Guide and Tensioner Failure (VQ40DE) ($1,500-$3,000 repair), Frame Rust and Corrosion (Recall R1601) ($0-$8,000 repair), Radiator SMOD - Strawberry Milkshake of Death (Transmission Cooler Failure), IPDM ECM Relay Defect on 2005-2006 Frontier (Safety Recall 10V517000), Timing Chain Rattle and Failure (QR25DE 4-Cylinder) ($800-$1,500 repair), Rear Timing Cover Oil Gallery Gasket Blowout Causing Low Oil Pressure at Idle (VQ40DE) ($1,200-$3,000 repair) and RE5R05A 5-Speed Valve Body and Integrated TCM Solenoid Failure Causing Limp Mode ($900-$3,500 repair). The most commonly reported issue is Timing Chain Guide and Tensioner Failure (VQ40DE) with 2,100 owner reports. Across all issues with published estimates, repair costs range from $30 to $8,000. DIY maintenance guides at .

Frequently Asked Questions

What are the most common Nissan Frontier problems?

According to Au7o's analysis of 3,600+ owner reports, the 2006 Nissan Frontier has 14 documented issues. The most frequently reported are: Timing Chain Guide and Tensioner Failure (VQ40DE), Frame Rust and Corrosion (Recall R1601), Radiator SMOD - Strawberry Milkshake of Death (Transmission Cooler Failure). Of these, 7 are rated critical and should be addressed promptly.

Is the Nissan Frontier reliable?

The 2006 Nissan Frontier has 14 known issues documented across 3,600+ owner reports. 7 issues are rated critical: Timing Chain Guide and Tensioner Failure (VQ40DE) and Frame Rust and Corrosion (Recall R1601) and Radiator SMOD - Strawberry Milkshake of Death (Transmission Cooler Failure) and IPDM ECM Relay Defect on 2005-2006 Frontier (Safety Recall 10V517000) and Timing Chain Rattle and Failure (QR25DE 4-Cylinder) and Rear Timing Cover Oil Gallery Gasket Blowout Causing Low Oil Pressure at Idle (VQ40DE) and RE5R05A 5-Speed Valve Body and Integrated TCM Solenoid Failure Causing Limp Mode. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Nissan Frontier problems?

Repair costs for known Nissan Frontier issues range from $0 to $8,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Timing Chain Guide and Tensioner Failure (VQ40DE), typically costs $1,500-$3,000 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 2005-2019 Nissan Frontier Timing Chain Guide and Tensioner Failure (VQ40DE)?

The Nissan Frontier VQ40DE 4.0L V6 is notorious for timing chain guide and tensioner failure, typically occurring between 80,000-130,000 miles. The plastic chain guides deteriorate and break apart, causing chain rattle and potential engine damage. This is one of the most well-kno… Repairs typically run $1,500-$3,000. Severity: high.

All 14 Known Issues

Other Nissan Models

Frequently Asked Questions

What are the most common Nissan Frontier problems?

Is the Nissan Frontier reliable?

How much does it cost to fix common Nissan Frontier problems?

What is the 2005-2019 Nissan Frontier Timing Chain Guide and Tensioner Failure (VQ40DE)?

What is the 2005-2012 Nissan Frontier Frame Rust and Corrosion (Recall R1601)?

When Issues Typically Appear

2005-2019 Nissan Frontier: Timing Chain Guide and Tensioner Failure (VQ40DE)#

2005-2012 Nissan Frontier: Timing Chain Rattle and Failure (QR25DE 4-Cylinder)#

2005-2019 Nissan Frontier: Rear Timing Cover Oil Gallery Gasket Blowout Causing Low Oil Pressure at Idle (VQ40DE)#

2005-2012 Nissan Frontier: Frame Rust and Corrosion (Recall R1601)#

2005-2010 Nissan Frontier: Radiator SMOD - Strawberry Milkshake of Death (Transmission Cooler Failure)#

2005-2006 Nissan Frontier: IPDM ECM Relay Defect on 2005-2006 Frontier (Safety Recall 10V517000)#

2005-2019 Nissan Frontier: RE5R05A 5-Speed Valve Body and Integrated TCM Solenoid Failure Causing Limp Mode#

2005-2025 Nissan Frontier: Transfer Case Shift Actuator Motor and Position Switch Failure - 4WD Will Not Engage#

2005-2021 Nissan Frontier: Rear Differential Bushing Clunk#

2005-2019 Nissan Frontier: Catalytic Converter Efficiency Failure (P0420 / P0430) on the 4.0L VQ40DE#

2005-2024 Nissan Frontier: Wheel Speed Sensor Corrosion Triggering ABS, VDC OFF and SLIP Warning Lights#

2005-2019 Nissan Frontier: Fuel Sending Unit Failure and Inaccurate Gauge#

2005-2021 Nissan Frontier: Rear Leaf Spring Sag and Flat Bed Syndrome#

2005-2021 Nissan Frontier: HVAC Blend Door Actuator Failure Causing No Heat and Clicking Under the Dash#