What are the most common Toyota MR2 problems?
According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 1987 Toyota MR2 has 5 documented issues. The most frequently reported are: 4A-GE Oil Starvation and Rod Bearing Wear Under Hard Cornering, Structural Rust: Trailing-Arm Mounts, Rockers, Arches and Front Crossmember (AW11), T-Top and T-Bar Roof Water Leaks. Of these, 2 are rated critical and should be addressed promptly.
Is the Toyota MR2 reliable?
The 1987 Toyota MR2 has 5 known issues compiled from NHTSA recalls, manufacturer TSBs, and owner forum reports. 2 issues are rated critical: 4A-GE Oil Starvation and Rod Bearing Wear Under Hard Cornering and Structural Rust: Trailing-Arm Mounts, Rockers, Arches and Front Crossmember (AW11). Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common Toyota MR2 problems?
Repair costs for known Toyota MR2 issues range from $100 to $5,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, 4A-GE Oil Starvation and Rod Bearing Wear Under Hard Cornering, typically costs $500-$5,000 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 1985-1989 Toyota MR2 4A-GE Oil Starvation and Rod Bearing Wear Under Hard Cornering?
The 4A-GE's small unbaffled sump lets oil slosh away from the pickup during sustained high-G cornering on sticky tires, momentarily starving the rod (big-end) bearings; the engine also runs very hot oil temperatures (140-170°C is reported without a cooler), which thins the oil an… Repairs typically run $500-$5,000. Severity: high.
What is the 1985-1989 Toyota MR2 Structural Rust: Trailing-Arm Mounts, Rockers, Arches and Front Crossmember (AW11)?
First-generation MR2s rust aggressively in structural areas: the frame sections under the rear trailing-arm mounts, the rocker panels and B-pillar/sill junctions, the spot-welded rear fender arch seams, the battery tray, and the steel crossmember behind the front nosecone. Owners… Repairs typically run $500-$5,000. Severity: high.
What is the 1987-1995 Toyota MR2 T-Top and T-Bar Roof Water Leaks?
The removable glass roof panels on T-bar AW11s and T-top SW20s leak persistently as the factory weatherstripping hardens and the roof drain channels and tubes clog or dislodge — some drain tubes even end up routed into the interior. Water soaks the carpets and seats, causes musty… Repairs typically run $150-$900. Severity: medium.
What is the 1985-1989 Toyota MR2 C50/C52 Gearbox Pops Out of Fifth Gear (AW11)?
The AW11's C-series transaxle is notorious for jumping out of fifth gear into neutral, typically when backing off the throttle at highway speed. The root cause is worn output shaft bearings sitting directly under fifth gear (aggravated by worn shift detents and synchro hub wear);… Repairs typically run $800-$2,500. Severity: medium.
What is the 1985-1995 Toyota MR2 Cooling System Airlocks From Improper Bleeding (Mid-Engine Layout)?
Because the MR2's engine sits in the middle of the car while the radiator is in the nose, roughly 20 feet of coolant piping runs under the cabin, and the system traps air pockets very easily after any coolant service. Trapped air passes the coolant temperature sensors and gives t… Repairs typically run $100-$250. Severity: medium.
