What is the 2002-2003 Cadillac DeVille Recall 03V238000: Fuel Tank Pressure Sensor Can Cause Fuel Leak and Fire?

NHTSA safety recall 03V238000 covers 2002-2003 Cadillac DeVille models built with the 4.6L V8 - including the funeral coach and limousine versions built on this platform, which are named explicitly in the campaign alongside the standard passenger cars. On these vehicles the fuel… Severity: high.

What is the 2000-2005 Cadillac DeVille Key Ring Weight Can Knock the Ignition Out of Run - Recall 14V355000?

The 2000-2005 Cadillac DeVille is one of the vehicles included in GM recall 14V355000, filed under electrical system: ignition. The defect is that the ignition switch can be moved out of the run position by the weight on the key ring together with road conditions or another jarri… Severity: high.

What is the 1996-2005 Cadillac DeVille Crankshaft Position Sensor Failure Causes Stalling, No-Start and P0335/P0336/P0385?

The Northstar uses two crankshaft position sensors (commonly referred to as the upper/A and lower/B 24x sensors) mounted low on the block behind the oil filter adapter area. The original Siemens-sourced sensors are widely reported by DeVille owners to fail with age and heat, sett… Repairs typically run $150-$500. Severity: high.

What is the 1996-2005 Cadillac DeVille Northstar 4.6L Engine Oil Leak (Rear Main Seal and Crankcase)?

All Northstar 4.6L engines eventually develop oil leaks from multiple locations: rear main seal, lower crankcase gasket, valve cover gaskets, oil pan gasket, and oil pressure sender. The rear main seal is the most expensive to address as it requires engine removal or separation f… Repairs typically run $200-$2,000. Severity: medium.

What is the 1994-2005 Cadillac DeVille High Oil Use Needs a Measured Consumption Test Before Repair (01-06-01-011O)?

GM bulletin 01-06-01-011O covers 2024 and prior GM passenger cars and explains that oil use varies with driving, maintenance, leaks and engine condition. It requires each case to be evaluated and does not establish a universal Northstar defect. Its one-quart-per-2,000-mile guidel… Severity: medium.

What is the 1994-2005 Cadillac DeVille Sunroof Drain Tubes Detach or Clog and Flood the Trunk and Rear Floor?

Sunroof-equipped DeVilles route four drain tubes down the pillars. Owners document that GM retained the tubes with clips backed by double-sided tape that fails with age: the tube sags, pulls partly out of the rubber grommet where it passes through the fender/quarter, and water th… Repairs typically run $50-$500. Severity: medium.

What is the 1994-2005 Cadillac DeVille Starter Buried in the Engine Valley Under the Intake Manifold Turns a Small Failure Into a Big Bill?

On the Northstar-powered DeVille the starter motor sits in the engine valley beneath the plastic upper intake manifold, not on the outside of the bellhousing. When the starter solenoid or motor fails - reported symptoms are a single loud click with no crank, slow cranking on a kn… Repairs typically run $450-$1,200. Severity: medium.

What is the 1996-2005 Cadillac DeVille Electronic Brake Control Module (EBCM) Failure Lights ABS, Brake and Traction Control Warnings?

The Bosch electronic brake/traction control module mounted on the hydraulic unit fails internally on high-mileage DeVilles. Owners report ABS, BRAKE and Traction Control warning lamps illuminated together - sometimes intermittently at first - a scan tool that cannot establish com… Repairs typically run $200-$900. Severity: medium.

What is the 1994-2005 Cadillac DeVille Rear Electronic Level Control Air Shocks Leak and the Compressor Fails, Leaving the Rear Sagging?

DeVilles fitted with Electronic Level Control use coil springs at all four corners with air-bladder shocks at the rear that only trim ride height. The rubber bladders on the rear shocks dry out and split, the air lines and fittings leak at the crimps, and the compressor's air dry… Repairs typically run $300-$1,100. Severity: medium.

What is the 2000-2005 Cadillac DeVille HVAC Blend Door Actuator Failure?

The blend door actuator motor fails, causing the HVAC system to blow only hot or only cold air regardless of the temperature setting. The DeVille uses multiple actuators for its dual-zone climate control, and a clicking or tapping noise from behind the dash is the telltale sign o… Repairs typically run $80-$300. Severity: low.

Cadillac · Known Issues

2002 Cadillac DeVille Problems: 13 Known Issues

2002 model year · NHTSA recalls, manufacturer TSBs, and owner forum reports · Updated August 2026

Share:@au7o.io

According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 2002 Cadillac DeVille has 13 documented known issues, with 6 rated critical. The most serious are Northstar 4.6L V8 Head Bolt/Head Gasket Failure ($3,000-$6,000 repair), Recall 03V238000: Fuel Tank Pressure Sensor Can Cause Fuel Leak and Fire, Key Ring Weight Can Knock the Ignition Out of Run - Recall 14V355000, Crankshaft Position Sensor Failure Causes Stalling, No-Start and P0335/P0336/P0385 ($150-$500 repair), Recall 02V227000: Front Seat Belt Retractors May Not Stay Locked When the Pretensioners Fire ($0-$0 repair) and 4T80-E Lower Valve Body and Fourth-Gear Clutch Failure Causes Slipping and Lost Overdrive ($600-$4,000 repair). Across all issues with published estimates, repair costs range from $50 to $6,000. DIY maintenance guides at au7o.io.

Frequently Asked Questions

What are the most common Cadillac DeVille problems?

According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 2002 Cadillac DeVille has 13 documented issues. The most frequently reported are: Northstar 4.6L V8 Head Bolt/Head Gasket Failure, Recall 03V238000: Fuel Tank Pressure Sensor Can Cause Fuel Leak and Fire, Key Ring Weight Can Knock the Ignition Out of Run - Recall 14V355000. Of these, 6 are rated critical and should be addressed promptly.

Is the Cadillac DeVille reliable?

The 2002 Cadillac DeVille has 13 known issues compiled from NHTSA recalls, manufacturer TSBs, and owner forum reports. 6 issues are rated critical: Northstar 4.6L V8 Head Bolt/Head Gasket Failure and Recall 03V238000: Fuel Tank Pressure Sensor Can Cause Fuel Leak and Fire and Key Ring Weight Can Knock the Ignition Out of Run - Recall 14V355000 and Crankshaft Position Sensor Failure Causes Stalling, No-Start and P0335/P0336/P0385 and Recall 02V227000: Front Seat Belt Retractors May Not Stay Locked When the Pretensioners Fire and 4T80-E Lower Valve Body and Fourth-Gear Clutch Failure Causes Slipping and Lost Overdrive. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Cadillac DeVille problems?

Repair costs for known Cadillac DeVille issues range from $0 to $6,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Northstar 4.6L V8 Head Bolt/Head Gasket Failure, typically costs $3,000-$6,000 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 1994-2005 Cadillac DeVille Northstar 4.6L V8 Head Bolt/Head Gasket Failure?

The Cadillac Northstar 4.6L V8 is infamous for head gasket failure caused by the head bolts pulling out of the aluminum engine block. The original design used steel bolts threaded directly into the aluminum block without inserts, and the threads strip over time from heat cycling. Repairs typically run $3,000-$6,000. Severity: high.

All 13 Known Issues

Other Cadillac Models

Frequently Asked Questions

What are the most common Cadillac DeVille problems?

Is the Cadillac DeVille reliable?

How much does it cost to fix common Cadillac DeVille problems?

What is the 1994-2005 Cadillac DeVille Northstar 4.6L V8 Head Bolt/Head Gasket Failure?

1994-2005 Cadillac DeVille: Northstar 4.6L V8 Head Bolt/Head Gasket Failure#

1996-2005 Cadillac DeVille: Crankshaft Position Sensor Failure Causes Stalling, No-Start and P0335/P0336/P0385#

1996-2005 Cadillac DeVille: Northstar 4.6L Engine Oil Leak (Rear Main Seal and Crankcase)#

1994-2005 Cadillac DeVille: High Oil Use Needs a Measured Consumption Test Before Repair (01-06-01-011O)#

2000-2005 Cadillac DeVille: Key Ring Weight Can Knock the Ignition Out of Run - Recall 14V355000#

1994-2005 Cadillac DeVille: Starter Buried in the Engine Valley Under the Intake Manifold Turns a Small Failure Into a Big Bill#

2002-2003 Cadillac DeVille: Recall 03V238000: Fuel Tank Pressure Sensor Can Cause Fuel Leak and Fire#

2000-2002 Cadillac DeVille: Recall 02V227000: Front Seat Belt Retractors May Not Stay Locked When the Pretensioners Fire#

1994-2005 Cadillac DeVille: 4T80-E Lower Valve Body and Fourth-Gear Clutch Failure Causes Slipping and Lost Overdrive#

1994-2005 Cadillac DeVille: Sunroof Drain Tubes Detach or Clog and Flood the Trunk and Rear Floor#

1996-2005 Cadillac DeVille: Electronic Brake Control Module (EBCM) Failure Lights ABS, Brake and Traction Control Warnings#

1994-2005 Cadillac DeVille: Rear Electronic Level Control Air Shocks Leak and the Compressor Fails, Leaving the Rear Sagging#

2000-2005 Cadillac DeVille: HVAC Blend Door Actuator Failure#