What are the most common Tesla Model S problems?
According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 2018-2018 Tesla Model S has 13 documented issues. The most frequently reported are: Model S / X Drive Unit "Milling" Noise / Failure, Model S / X MCU1 eMMC Flash Memory Failure, Drive Unit / Battery Coolant Leak (LDU Rotor Seal & Cooling Lines). Of these, 5 are rated critical and should be addressed promptly.
Is the Tesla Model S reliable?
The 2018-2018 Tesla Model S has 13 known issues compiled from NHTSA recalls, manufacturer TSBs, and owner forum reports. 5 issues are rated critical: Model S / X Drive Unit "Milling" Noise / Failure and Model S / X MCU1 eMMC Flash Memory Failure and Drive Unit / Battery Coolant Leak (LDU Rotor Seal & Cooling Lines) and 12V Auxiliary Battery / DC-DC Converter Failure Cascade and High-Voltage Battery Pack Failure - BMS_u029 Fault. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common Tesla Model S problems?
Repair costs for known Tesla Model S issues range from $0 to $22,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Model S / X Drive Unit "Milling" Noise / Failure, typically costs $0-$6,500 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 2012-2020 Tesla Model S Model S / X Drive Unit "Milling" Noise / Failure?
Early Model S (and X) drive units develop a "milling" noise — a metallic whine that gradually grows louder, ultimately requiring drive-unit replacement. Tesla has replaced many DUs under warranty (often multiple times per car). Issue stems from gear-mesh quality and bearing toler… Repairs typically run $0-$6,500. Severity: high.
What is the 2012-2018 Tesla Model S Model S / X MCU1 eMMC Flash Memory Failure?
The MCU1 (Tegra 3-based infotainment) used in 2012-2018 Model S and 2016-2018 Model X has a chronic eMMC flash memory wear-out issue — the 8GB eMMC accumulates write cycles from system logging until it fails, taking the rearview camera, defrost/defog controls, turn-signal lightin… Repairs typically run $0-$2,500. Severity: high.
What is the 2012-2019 Tesla Model S Drive Unit / Battery Coolant Leak (LDU Rotor Seal & Cooling Lines)?
Early Model S large drive units (LDU) have a known internal coolant leak where the rotor shaft seal fails and coolant migrates into the drive unit, and separately the battery/drive-unit cooling lines and fittings crack or seep with age. Leaks rarely show as a puddle; instead owne… Repairs typically run $300-$4,500. Severity: high.
What is the 2012-2021 Tesla Model S 12V Auxiliary Battery / DC-DC Converter Failure Cascade?
The low-voltage 12V lead-acid battery on early-to-mid Model S (concentrated in 2015-2018 build years) fails prematurely due to a poor original vendor cell plus constant vampire-load strain from always-on electronics. Roughly a third of Tesla NHTSA low-voltage complaints trace her… Repairs typically run $220-$1,800. Severity: high.
What is the 2012-2018 Tesla Model S High-Voltage Battery Pack Failure - BMS_u029 Fault?
The BMS_u029 alert ('maximum battery charge level reduced' / unable to charge to full) is a widely-reported code that has effectively killed a number of early Model S high-voltage packs. The Battery Management System detects a condition (module isolation drift, contactor concern,… Repairs typically run $2,000-$22,000. Severity: high.
What is the 2012-2020 Tesla Model S Model S / X Air Suspension Leveling / Nose-Droop?
Model S and X with air suspension develop leveling-pump and air-strut failures — typically presenting as a nose-droop overnight (car settles unevenly) or "Air Suspension Needs Service" warning. Pump diaphragm wear is the most common single cause; corner air struts also leak. Comm… Repairs typically run $500-$4,000. Severity: medium.
What is the 2012-2021 Tesla Model S Charge Port Door / Latch Actuator Failure?
The charge port door fails to open on command, or the internal latch fails to lock/release the charge cable. The actuator motor stops engaging the latch mechanism, or the electrical command isn't fulfilled, so the door won't 'push-to-open,' won't close, or the connector locks/unl… Repairs typically run $150-$700. Severity: medium.
What is the 2012-2020 Tesla Model S Retractable Door Handle Failure (Paddle Gear / Actuator Wear)?
The Model S's flush, auto-presenting exterior door handles are the single most-complained-about item on the car (the #1 issue in Consumer Reports' survey of ~1,300 owners). The small plastic 'paddle gear' inside the handle that transfers the pull to the latch cracks under materia… Repairs typically run $120-$600. Severity: medium.
What is the 2012-2018 Tesla Model S Panoramic Sunroof Water Leak?
Model S cars fitted with the optional panoramic (opening) glass roof are prone to water leaking into the cabin during heavy rain. Root causes include an improperly seated rear rubber seal, the early 2014-design seal channel that has an opening at the rear (so when parked nose-dow… Repairs typically run $0-$900. Severity: medium.
What is the 2013-2021 Tesla Model S Electronic Parking Brake Caliper Seizure (EPB Motor Failure)?
The rear integrated electronic parking brake (EPB) calipers seize or the caliper actuator motor fails, throwing 'EPB_w053 - Parking brake did not release' or 'EPB_w052 - Parking brake functions degraded.' The caliper shaft can seize (often from moisture/corrosion in cars driven l… Repairs typically run $350-$1,600. Severity: medium.
What is the 2012-2018 Tesla Model S Center Touchscreen Yellow Border & LCD Delamination/Bubbling?
The 17-inch center touchscreen develops a yellow band around its border as the display's optical bonding adhesive yellows when heat, humidity and oxygen reach it over time - very common on 2012-2017 cars, especially in warm climates. A related and more serious defect is LCD bubbl… Repairs typically run $0-$1,500. Severity: low.
What is the 2012-2020 Tesla Model S Power Window Regulator Failure (Plastic Ferrule Design Flaw)?
The window regulator on Model S doors fails because of a weak plastic ferrule in the regulator assembly that cracks, letting the glass come off its track or float free in the door. Owners report grinding/crunching or cracking noises raising and lowering the glass, glass that stic… Repairs typically run $20-$450. Severity: low.
What is the 2012-2020 Tesla Model S Frunk (Front Trunk) Hood Latch Actuator / Cable Failure?
The front trunk ('frunk') fails to open on command because the electric hood latch actuator fails or the release cables corrode/seize or the latch goes misaligned. Owners hear the actuator working but the hood won't pop, or the dash reports 'front trunk / hood latch position unkn… Repairs typically run $0-$400. Severity: low.
