What are the most common Volvo S60 problems?
According to Au7o's research across NHTSA recalls, manufacturer TSBs, and owner forum reports, the 2007 Volvo S60 has 7 documented issues. The most frequently reported are: AW55-50SN 5-Speed Automatic Transmission and TCM Failure, Rear Shock Tower and Trunk Floor Corrosion, Rear Electronic Module (REM) Water Damage. Of these, 2 are rated critical and should be addressed promptly.
Is the Volvo S60 reliable?
The 2007 Volvo S60 has 7 known issues compiled from NHTSA recalls, manufacturer TSBs, and owner forum reports. 2 issues are rated critical: AW55-50SN 5-Speed Automatic Transmission and TCM Failure and Rear Shock Tower and Trunk Floor Corrosion. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common Volvo S60 problems?
Repair costs for known Volvo S60 issues range from $150 to $4,500, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, AW55-50SN 5-Speed Automatic Transmission and TCM Failure, typically costs $900-$4,500 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 2001-2009 Volvo S60 AW55-50SN 5-Speed Automatic Transmission and TCM Failure?
P2-generation S60s use the Aisin-Warner AW55-50SN 5-speed automatic. Two related failures dominate owner reports: the transmission control module (TCM), which is mounted inside the transmission case and bathed in hot ATF, develops cracked solder joints and internal failures, and… Repairs typically run $900-$4,500. Severity: high.
What is the 2001-2009 Volvo S60 Rear Shock Tower and Trunk Floor Corrosion?
First-generation S60 models are prone to severe rust in the rear shock tower mounting points and trunk floor, particularly in salt-belt regions. Water intrusion through deteriorated trunk seals and blocked drain holes accelerates the corrosion. In advanced cases, the shock tower… Repairs typically run $500-$2,500. Severity: high.
What is the 2001-2009 Volvo S60 Rear Electronic Module (REM) Water Damage?
The Volvo S60 P2 platform has the Rear Electronic Module (REM) located in the trunk area where it is susceptible to water intrusion from trunk seal leaks or condensation. Water damage causes intermittent electrical failures in rear lighting, fuel pump, and other circuits. Repairs typically run $200-$800. Severity: medium.
What is the 2001-2007 Volvo S60 In-Tank Fuel Pump Module and Fuel Level Sender Failure?
Fuel system complaints are the single largest NHTSA category on the early P2 S60 (roughly 74 complaints on the 2002 and 92 on the 2001). Two distinct parts fail. The fuel level sender's resistive card wears where the wiper arm sweeps, so the gauge reads erratically, sticks full,… Repairs typically run $350-$1,100. Severity: medium.
What is the 2001-2009 Volvo S60 DIM (Driver Information Module) Instrument Cluster Solder Joint Failure?
The P2 S60's instrument cluster is a self-contained module (DIM) that sits on the CAN bus. Thermal cycling in the dash cracks the solder joints where the cluster's connector pins and internal components attach to the circuit board. The result is intermittent, then permanent, clus… Repairs typically run $250-$900. Severity: medium.
What is the 2001-2009 Volvo S60 Thermostat Housing Coolant Leak (Turbo 5-Cylinder)?
The plastic thermostat housing on P2-platform S60 turbo models (T5 and 2.4T) is prone to cracking and leaking coolant, especially as the housing ages and becomes brittle from heat cycling. The leak typically starts as a slow seep around the housing gasket or where the housing mee… Repairs typically run $200-$500. Severity: medium.
What is the 2001-2009 Volvo S60 Upper Engine Mount (Torque Rod) Failure?
The upper engine torque mount on P2-platform S60 models is a common wear item that fails between 60,000-100,000 miles. The hydraulic-filled mount splits and leaks fluid, causing excessive engine movement during acceleration and deceleration. This leads to harsh shifting feel, dri… Repairs typically run $150-$400. Severity: medium.
