What is the 2019-2022 Volvo V60 Fuel Pump Module Failure and Recall?

The in-tank fuel pump module fails, causing stalling, no-start, or loss of power while driving. Volvo issued recall R10090 for certain production date ranges. The plastic fuel pump housing cracks from fuel exposure over time. Repairs typically run $200-$800. Severity: high.

What is the 2019-2020 Volvo V60 V60 and V60 Cross Country AEB May Not Detect Obstacles (NHTSA 20V144000)?

NHTSA recall 20V144000 covers 2019-2020 V60 and V60 Cross Country wagons. Volvo reported a software/hardware incompatibility under which the Automatic Emergency Brake system may fail to detect obstacles and may not engage as intended. The recall consequence stated by NHTSA is an… Severity: high.

What is the 2020-2024 Volvo V60 T8 Recharge Plug-In Hybrid 12V Battery Drain and No-Start?

T8 plug-in hybrid V60s repeatedly suffer a discharged 12V starter battery, leaving the car dead and unable to start even when the high-voltage drive battery is full of charge. The 12V is supposed to be topped up by a DC-DC inverter fed from the 300V pack, but the inverter sometim… Repairs typically run $300-$1,500. Severity: high.

What is the 2019-2023 Volvo V60 T5/T6 Engine Excessive Oil Consumption?

The V60 shares the same 2.0L T5 and T6 powertrains as the S60 and XC60, and experiences the same excessive oil consumption issue. Oil consumption of 1 quart per 2,000-3,500 miles is commonly reported, particularly at sustained highway speeds. The issue is more pronounced in T6 tw… Repairs typically run $0-$5,000. Severity: medium.

What is the 2015-2025 Volvo V60 Aisin 8-Speed Transmission Hesitation and Shudder?

The Aisin 8-speed automatic transmission exhibits hesitation during low-speed acceleration and a shudder during light throttle cruising around 35-50 mph. The transmission control software hunting between gears is a contributing factor. Repairs typically run $0-$2,000. Severity: medium.

What is the 2015-2023 Volvo V60 Sensus Infotainment Freezing, Black Screen and Reboot Loops?

The Sensus Connect center display freezes, goes black/blank, or gets stuck in a boot loop cycling the Volvo logo without fully loading. Because the touchscreen controls climate, radio volume, backup camera, and many vehicle settings, a frozen unit also kills audio, turn-signal/pa… Repairs typically run $150-$1,800. Severity: medium.

What is the 2011-2022 Volvo V60 Sunroof / Moonroof Drain Clogging and Cabin Water Leaks?

The V60's sunroof/panoramic roof relies on four corner drain tubes that route rainwater down the pillars and out of the car. These drains clog with debris or pollen, and the tubes (which use intermediate connectors) can kink, crack, or pop loose. When they fail, water backs up an… Repairs typically run $100-$600. Severity: medium.

What is the 2019-2023 Volvo V60 Front Upper Control Arm Hydro-Bushing Clunk (SPA Platform)?

The second-generation V60 on Volvo's SPA platform uses fluid-filled 'hydro-bushings' in the front upper control arms. These bushings leak and deteriorate, producing a distinct clunk, pop, or knock from the front suspension over bumps, potholes, and uneven pavement. Owners report… Repairs typically run $300-$800. Severity: medium.

What is the 2019-2025 Volvo V60 Premature Rear Brake Pad and Rotor Wear?

The V60 is widely reported for premature rear brake pad and rotor wear, with rear brakes wearing out 2-3 times faster than the fronts. Rear pads can be worn to minimum thickness by 20,000-30,000 miles while front pads still have 60%+ life remaining. The aggressive rear brake bias… Repairs typically run $300-$800. Severity: low.

What is the 2019-2024 Volvo V60 Cross Country Raised Suspension Strut Top Mount Noise?

The V60 Cross Country with its raised suspension develops strut top mount bearing noise, particularly over rough roads and during slow-speed turning. The front strut top mounts (also called upper strut bearings) wear prematurely due to the increased suspension travel and heavier… Repairs typically run $400-$1,200. Severity: low.

What is the 2015-2023 Volvo V60 Power Tailgate Strut / Drive-Unit Failure — Won't Power-Close or Sinks After Opening?

The optional power tailgate is a recurring complaint, most prominently on the second-generation (2019+) V60. Owners report the tailgate unlatches and opens but won't power-close from any control (under-hatch button, key fob, kick sensor, or dash button), stops partway, sinks a fe… Repairs typically run $200-$900. Severity: low.

Volvo · Known Issues

2020 Volvo V60 Problems: 14 Known Issues

2020 model year · 1,830+ owner reports · Updated September 2026

Share:@au7o.io

According to Au7o's analysis of 1,830+ owner reports, the 2020 Volvo V60 has 14 documented known issues, with 6 rated critical. The most serious are V60 Low-Pressure Fuel Pump Fuse Failure and Stalling (Recall 21V414000), AdBlue / SCR NOx Sensor Faults and Start-Prevented Countdown ($300-$1,200 repair), Recall 25V179000 — V60 Recharge Wagon High-Voltage Battery Fire Risk When Parked at Full Charge, Fuel Pump Module Failure and Recall ($200-$800 repair), V60 and V60 Cross Country AEB May Not Detect Obstacles (NHTSA 20V144000) and T8 Recharge Plug-In Hybrid 12V Battery Drain and No-Start ($300-$1,500 repair). The most commonly reported issue is Premature Rear Brake Pad and Rotor Wear with 870 owner reports. Across all issues with published estimates, repair costs range from $100 to $5,000. DIY maintenance guides at au7o.io.

Frequently Asked Questions

What are the most common Volvo V60 problems?

According to Au7o's analysis of 1,830+ owner reports, the 2020 Volvo V60 has 14 documented issues. The most frequently reported are: V60 Low-Pressure Fuel Pump Fuse Failure and Stalling (Recall 21V414000), AdBlue / SCR NOx Sensor Faults and Start-Prevented Countdown, Recall 25V179000 — V60 Recharge Wagon High-Voltage Battery Fire Risk When Parked at Full Charge. Of these, 6 are rated critical and should be addressed promptly.

Is the Volvo V60 reliable?

The 2020 Volvo V60 has 14 known issues documented across 1,830+ owner reports. 6 issues are rated critical: V60 Low-Pressure Fuel Pump Fuse Failure and Stalling (Recall 21V414000) and AdBlue / SCR NOx Sensor Faults and Start-Prevented Countdown and Recall 25V179000 — V60 Recharge Wagon High-Voltage Battery Fire Risk When Parked at Full Charge and Fuel Pump Module Failure and Recall and V60 and V60 Cross Country AEB May Not Detect Obstacles (NHTSA 20V144000) and T8 Recharge Plug-In Hybrid 12V Battery Drain and No-Start. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Volvo V60 problems?

Repair costs for known Volvo V60 issues range from $0 to $5,000, depending on the specific problem and whether you choose DIY or professional repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 2019-2020 Volvo V60 V60 Low-Pressure Fuel Pump Fuse Failure and Stalling (Recall 21V414000)?

Owners of 2019-2020 V60 models - including the V60 Cross Country body style named in the same campaign - should be aware of Volvo Car USA's recall for a low-pressure fuel pump that can blow a fuse and fail. The practical result for the driver is an engine stall, and NHTSA cites t… Severity: high.

What is the 2016-2021 Volvo V60 AdBlue / SCR NOx Sensor Faults and Start-Prevented Countdown?

On AdBlue/SCR-equipped diesel V60s, faults in the NOx sensors and AdBlue dosing system are common. A drifting or failed NOx sensor makes the system believe the SCR catalyst is not reducing emissions, throwing AdBlue/dosing warnings and limp mode. Critically, persistent NOx/SCR fa… Repairs typically run $300-$1,200. Severity: high.

All 14 Known Issues

Other Volvo Models

Frequently Asked Questions

What are the most common Volvo V60 problems?

Is the Volvo V60 reliable?

How much does it cost to fix common Volvo V60 problems?

What is the 2019-2020 Volvo V60 V60 Low-Pressure Fuel Pump Fuse Failure and Stalling (Recall 21V414000)?

What is the 2016-2021 Volvo V60 AdBlue / SCR NOx Sensor Faults and Start-Prevented Countdown?

2020-2022 Volvo V60: Recall 25V179000 — V60 Recharge Wagon High-Voltage Battery Fire Risk When Parked at Full Charge#

2020-2024 Volvo V60: T8 Recharge Plug-In Hybrid 12V Battery Drain and No-Start#

2015-2023 Volvo V60: Sensus Infotainment Freezing, Black Screen and Reboot Loops#

2019-2020 Volvo V60: V60 Low-Pressure Fuel Pump Fuse Failure and Stalling (Recall 21V414000)#

2019-2022 Volvo V60: Fuel Pump Module Failure and Recall#

2016-2021 Volvo V60: AdBlue / SCR NOx Sensor Faults and Start-Prevented Countdown#

2019-2020 Volvo V60: V60 and V60 Cross Country AEB May Not Detect Obstacles (NHTSA 20V144000)#

2011-2022 Volvo V60: Sunroof / Moonroof Drain Clogging and Cabin Water Leaks#

2015-2023 Volvo V60: Power Tailgate Strut / Drive-Unit Failure — Won't Power-Close or Sinks After Opening#

2019-2023 Volvo V60: Front Upper Control Arm Hydro-Bushing Clunk (SPA Platform)#

2019-2024 Volvo V60: Cross Country Raised Suspension Strut Top Mount Noise#

2019-2023 Volvo V60: T5/T6 Engine Excessive Oil Consumption#

2015-2025 Volvo V60: Aisin 8-Speed Transmission Hesitation and Shudder#

2019-2025 Volvo V60: Premature Rear Brake Pad and Rotor Wear#

What is the 2020-2022 Volvo V60 Recall 25V179000 — V60 Recharge Wagon High-Voltage Battery Fire Risk When Parked at Full Charge?