According to Au7o's analysis of 1,120+ owner reports, the 2013 GMC Savana has 11 documented known issues, with 5 rated critical. The most serious are Fuel Pump Module Failure and Hard Start / Stalling ($350-$900 repair), AFM Lifter Failure on V8 Vortec/EcoTec3 Engines ($3,500-$8,000 repair), Brake Line Corrosion and Brake Fluid Loss (Rust Belt) ($600-$2,000 repair), Cutaway Rear HVAC Blower Circuit Corrosion at Left B-Pillar - Fire Risk (Recall 23V-247) ($0-$0 repair) and 4L60E/4L65E Automatic Transmission 3-4 Clutch Pack Burnup and Overdrive Slip (Savana 1500) ($1,800-$3,200 repair). The most commonly reported issue is Fuel Pump Module Failure and Hard Start / Stalling with 430 owner reports. Across all issues with published estimates, repair costs range from $50 to $8,000. DIY maintenance guides at au7o.io.
General Motors LLC (GM) is recalling certain 2025 Chevrolet Express and GMC Savana vans. The impact beam located in the driver's side door may have improper welds.
Campaign #25V08700013/02/2025
TIRES:SIDEWALL
General Motors, LLC (GM) is recalling certain 2025-2026 Express Cutaway, and 2025-2026 Savana Cutaway vehicles. These vehicles may be equipped with a tire with sidewall damage.
Campaign #26V12700005/03/2026
SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
General Motors LLC (GM) is recalling certain 2025 Chevrolet Express and GMC Savana vehicles. The front passenger seat head restraint may have been improperly welded to the seat frame.
Campaign #25V29900008/05/2025
STEERING
General Motors, LLC (GM) is recalling certain 2025-2026 Express, and 2025-2026 Savana vehicles. The steering gear assembly may have a nut that was not properly tightened.
🔧
A mechanic who knows YOUR exact car
Answers tuned to your year, make, model & trim — not generic advice. Save your garage so it always has the right context.
Get ahead of GMC Savana problems — free
Leave your email and we'll alert you the moment there's a new recall or known issue for your GMC Savana. Free, no account needed.
According to Au7o's analysis of 1,120+ owner reports, the 2013 GMC Savana has 11 documented issues. The most frequently reported are: Fuel Pump Module Failure and Hard Start / Stalling, AFM Lifter Failure on V8 Vortec/EcoTec3 Engines, Brake Line Corrosion and Brake Fluid Loss (Rust Belt). Of these, 5 are rated critical and should be addressed promptly.
Is the GMC Savana reliable?
The 2013 GMC Savana has 11 known issues documented across 1,120+ owner reports. 5 issues are rated critical: Fuel Pump Module Failure and Hard Start / Stalling and AFM Lifter Failure on V8 Vortec/EcoTec3 Engines and Brake Line Corrosion and Brake Fluid Loss (Rust Belt) and Cutaway Rear HVAC Blower Circuit Corrosion at Left B-Pillar - Fire Risk (Recall 23V-247) and 4L60E/4L65E Automatic Transmission 3-4 Clutch Pack Burnup and Overdrive Slip (Savana 1500). Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common GMC Savana problems?
Repair costs for known GMC Savana issues range from $0 to $8,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Fuel Pump Module Failure and Hard Start / Stalling, typically costs $350-$900 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 2003-2020 GMC Savana Fuel Pump Module Failure and Hard Start / Stalling?
The GMC Savana (and Chevrolet Express) fuel pump module is known for premature failure between 80,000-140,000 miles, often stranding drivers without warning. The in-tank electric fuel pump motor burns out or the sending unit becomes erratic. Running the tank consistently below 1/… Repairs typically run $350-$900. Severity: high.
What is the 2010-2025 GMC Savana AFM Lifter Failure on V8 Vortec/EcoTec3 Engines?
GMC Savana vans equipped with 4.8L (L20), 5.3L (LM7), and 6.0L (L96) V8 engines with Active Fuel Management suffer the same AFM lifter collapse problem documented across the entire GM full-size truck/van lineup. The collapsible AFM lifters on deactivation cylinders fail between 6… Repairs typically run $3,500-$8,000. Severity: high.
Content on this page was compiled with AI assistance using NHTSA complaints, TSBs, owner reports, and public automotive data. While we strive for accuracy, this information may contain errors. Always verify repair procedures and specifications with your vehicle's service manual or a qualified mechanic.
Filter:
On the 2003-2023 GMC Savana, savana Cutaway chassis are built with an unused wiring circuit at the lower left B-pillar so that a final-stage upfitter can install an optional rear HVAC blower. When the upfitter leaves that circuit's connectors or cut wire ends unsealed, moisture and road contamination corrode the terminals over time. The corroded joint develops high resistance, draws excessive current, and can overheat enough to start a fire at the B-pillar. GM's field analysis identified eight related complaints, six of them alleging fires, with notice dates spanning 2018 to 2022. GM recalled 149,028 cutaways in April 2023 under NHTSA campaign 23V-247 (GM number N222386050); 10,440 of those were GMC Savana Cutaways and the balance were Chevrolet Express Cutaways, so this genuinely names the Savana rather than being an Express-only campaign. Build range: May 2002 through March 2023.
Common Symptoms
Burning or melted-plastic smell near the left B-pillar
Smoke from the lower left interior wall
Rear blower inoperative or intermittent
Blown fuses on the rear HVAC circuit
Fire at the lower left side of the body
How to Fix
Free recall remedy under NHTSA 23V-247 / GM N222386050: the dealer seals the rear HVAC blower motor circuit at the left B-pillar so the high-current-draw condition cannot develop. Owners of any 2003-2023 Savana Cutaway - especially ambulance, shuttle, box and RV upfits - should run the VIN at NHTSA.gov/recalls, because cutaway chassis frequently change hands as commercial equipment and recall notices do not follow them. If an upfitter has since added rear HVAC, have the connections inspected for corrosion at the same visit.
On the 1996-2014 GMC Savana, the ignition switch (electrical portion, not the lock cylinder) develops worn contacts, causing intermittent no-start, stalling while driving, or loss of electrical accessories. A well-known issue shared with the Chevy Express.
Replace the ignition switch assembly (ACDelco D1432D). The switch is located on the steering column behind the dash. This is the electrical switch, not the key cylinder. Relatively straightforward replacement.
On the 1996-2014 GMC Savana, the light-duty Savana 1500 uses the 4L60E (later 4L65E) four-speed, not the heavy-duty 4L80E fitted to 2500/3500 models, and it is the weak link of the lineup. In van duty the converter clutch and overdrive cycle constantly at city speeds, and the 3-4 clutch pack and its apply seals cook. Owners describe a van that drives normally for a few miles and then flares between 3rd and 4th, or revs like it is in neutral once hot. Forum reports on 1996-2002 5.0L/5.7L and 2003-2014 5.3L 1500 vans repeat the same pattern; a plugged filter and burned fluid are usually found at teardown. This is a 1500-specific chapter - it is not the 4L80E story and should not be read across to the 2500/3500.
No recall or GM special coverage exists. The real fix is a rebuild or reman 4L60E/4L65E with upgraded 3-4 clutch pack (more frictions, updated apply piston) and a new torque converter; a shop rebuild typically runs $1,800-$3,200 installed. Preventively, shorten the fluid-and-filter interval to roughly 50,000 miles and add an auxiliary transmission cooler - van duty cycles run the fluid far hotter than the truck the box was calibrated for. Early slip caught with only a plugged filter has occasionally been cured with a fluid and filter service, but once the 3-4 pack is burned only a rebuild corrects it.
On the 2010-2020 GMC Savana 6.0L V8 Vortec L96 (flex fuel), when the Savana 2500/3500 moved to the 6L90 six-speed for 2010, a new failure appeared that the old 4L80E did not have. GM's own service information for 2010-2014 Express and Savana vans with the 6.0L flex-fuel V8 and 6L90 acknowledges that torque converter clutch friction material wears faster than expected under high duty cycle use - towing, loaded cutaway bodies, sustained grades - and that the wear produces a driveline vibration or shudder. Owners feel it as a light-throttle judder at 40-60 mph, like driving over rumble strips, worst when the converter is in its slip-controlled lock range. The shed friction material then contaminates the fluid and works its way into the valve body and pump, which is how a shudder becomes a rebuild.
Shudder or vibration under light throttle at 40-60 mph
Feels like driving over rumble strips
Shudder disappears when transmission downshifts out of lock-up
Dark or burnt transmission fluid
Harsh shifts developing over time
How to Fix
No recall; this is warranty/bulletin territory. Fix it early: a complete fluid exchange with the correct DEXRON-VI plus a replacement torque converter (an upgraded LuK or billet-cover unit if the van tows) stops the progression, typically $900-$1,800. Do not simply add a friction modifier and keep driving - once debris has circulated, the valve body and pump are at risk and the repair escalates to $3,500-$5,000. On loaded commercial vans, shorten the transmission fluid interval and check for shudder at every service.
On the 2003-2020 GMC Savana, the GMC Savana (and Chevrolet Express) fuel pump module is known for premature failure between 80,000-140,000 miles, often stranding drivers without warning. The in-tank electric fuel pump motor burns out or the sending unit becomes erratic. Running the tank consistently below 1/4 generates heat that shortens pump life. Commercial use Savanas that frequently run low on fuel — common in fleet operations — see pump failures well before 80,000 miles. The fuel pump is a demanding repair requiring tank removal on the Savana.
Hard start or extended cranking before engine fires
Engine stalls at idle and won't restart when hot
Fuel pressure below specification (should be 55-60 psi)
Engine stumbles and hesitates under load
No-start condition with no fuel pressure
Fuel gauge erratic or reads wrong
How to Fix
Replace fuel pump module (ACDelco MU1374 for 6.0L Savana, MU1373 for 4.8L). Keep fuel tank above 1/4 full at all times. For fleet vehicles, replace pump proactively at 100,000 miles. Aftermarket Walbro or Delphi pumps are common alternatives.
High Confidence430 owner reportsLast reported by owners Feb 2026Reviewed Feb 2026
Community reported
350 owners
On the 2010-2025 GMC Savana, gMC Savana vans equipped with 4.8L (L20), 5.3L (LM7), and 6.0L (L96) V8 engines with Active Fuel Management suffer the same AFM lifter collapse problem documented across the entire GM full-size truck/van lineup. The collapsible AFM lifters on deactivation cylinders fail between 60,000-120,000 miles, causing misfires, engine ticking, rough idle, and potential engine damage. Commercial Savana vans used for fleet operations are especially vulnerable due to high mileage accumulation and variable maintenance practices. The problem affects all GMT600 platform Savana/Express vans with AFM-equipped engines.
Replace all 16 lifters and VLOM (GM 12639516). AFM delete kit for permanent fix. Range Technology RA003B disabler for prevention. Increase oil change frequency to 5,000 miles with Dexos2 full synthetic for commercial use vans.
High Confidence350 owner reportsLast reported by owners Feb 2026Reviewed Feb 2026
Community reported
340 owners
On the 2003-2014 GMC Savana, the 2003-2014 GMC Savana uses steel brake lines that are subject to severe corrosion in salt-belt states. The factory lines corrode from the outside in and can rupture without warning, causing catastrophic brake failure. This is the same safety-critical issue as documented across all GM full-size truck/van platforms of the same era. Commercial Savanas that operate year-round in Northern states, where road salt is used heavily, are at highest risk. NHTSA has received hundreds of complaints on brake line corrosion leading to loss of braking ability.
Common Symptoms
Soft or spongy brake pedal
Brake fluid level dropping with no external wheel leak
Visible rust or corrosion on brake lines under vehicle
Brake pedal traveling to floor
Brake warning light
Complete loss of braking after line rupture
How to Fix
Inspect all brake lines annually in rust-belt states. Replace corroded lines with Dorman stainless steel pre-bent replacement sets. Consider full brake line replacement as preventive maintenance at 100,000+ miles on any Savana that has lived in salt-belt states.
High Confidence340 owner reportsLast reported by owners Feb 2026Reviewed Feb 2026
On the 1996-2018 GMC Savana, savana and Express bodies rot in a predictable pattern: rocker panels beneath the front and sliding doors, the bottoms of the doors themselves, the lower rear quarters at the wheel arches, and the lower skins of the side cargo and rear doors. The doors rust from the inside out - water passes the weatherstrip, pools in the door bottom because the drains silt up, and by the time paint bubbles appear there is substantial metal loss behind it. Owners on van forums identify a specific aggravating design detail: where running boards are fitted, the assembly traps water, mud and road salt between the steel rocker panel and the fiberglass upper cladding, holding the rocker permanently wet. On a rust-belt commercial van this becomes structural, not cosmetic - the rocker is what the sliding door track and body mounts rely on.
Common Symptoms
Paint bubbling along the rocker panel below the doors
Rust holes at the bottom of the front or sliding doors
Perforation at the rear wheel arch
Water or debris packed behind running board cladding
Sliding door track loose or misaligned
Rust visible on the lower rear cargo door skins
How to Fix
No recall or corrosion warranty extension. Catch it early: clear the door drain holes at every service, and if the van has running boards, remove them periodically and clean out the packed debris between the rocker and the cladding. Once metal is perforated the fix is cut-and-weld with reproduction panels - outer rocker panels, lower door skins and wheel arch repair panels are all available for 1996-2018 vans and are e-coated for corrosion protection. Budget $400-$900 per rocker at a body shop and $300-$700 per lower door skin; both sides plus quarters on a badly rusted van easily reaches $3,000-$5,000. Bolt-on cover panels glued over rusted metal hide the problem and accelerate it.
On the 1996-2025 GMC Savana, the rear cargo doors and sliding side door hinges wear out from the weight of the doors and constant commercial use. Doors sag, become difficult to close, and the weatherstripping no longer seals properly.
Common Symptoms
Doors hard to close
Wind noise from door seals
Doors sag visibly
Water leaks around doors
How to Fix
Replace door hinge pins and bushings, or complete hinge assemblies if worn beyond bushing repair. Adjust door striker plates after hinge repair. Lubricate all hinge pivot points with white lithium grease every 6 months.
On the 1999-2020 GMC Savana, on the 4.8L, 5.3L and 6.0L Vortec V8s the exhaust manifold bolts - almost always the ones at the extreme front and rear of each cylinder head - snap from repeated thermal cycling, letting the manifold lift off the head. The classic symptom is a loud tick or 'exhaust leak' ticking at cold start that quiets as the engine expands and seals the gap. It is common enough on Savana and Express vans that fleet operators running 6.0L passenger vans report the front and rear bolts broken on both banks across their whole fleet. What makes this a van-specific problem rather than a generic truck one is access: the engine sits in a doghouse inside the cab, so the rear bolt near the firewall is extremely difficult to reach and the labor bill is far higher than on a Silverado with the same engine.
Loud ticking at cold start that fades as engine warms
Exhaust smell in cabin
Ticking that gets louder under acceleration
Soot streaks at the cylinder head/manifold joint
Failed emissions or O2 sensor codes from unmetered air
How to Fix
No recall. Correct repair is to extract the broken bolt stubs (drill and easy-out, or weld a nut to the stub), replace all manifold bolts with the updated design, and fit new manifold gaskets. On a van expect $600-$1,500 per side because of doghouse access - considerably more than the same job on a pickup. Manifold repair clamps that bridge a broken bolt are sold as a fix but are a temporary measure only. Inspect for a cracked manifold at the same time; a cracked casting ticks identically and must be replaced.
On the 1996-2014 GMC Savana, savana V8s develop intake manifold gasket leaks that show up either as an external drip - usually coolant down the driver's side of the block, or oil at the rear of the valley - or, worse, as an internal leak that lets coolant into the oil. Owners of 6.0L vans report antifreeze appearing on the driver's side with no hose failure to explain it; the same failure is documented on the earlier 5.7L and 7.4L Vortec engines. Left alone the loss of coolant leads to overheating, and a coolant-into-oil leak destroys bearings. Because the engine lives under the doghouse, the leak often shows up as coolant smell in the cab before a puddle appears under the van.
Common Symptoms
Coolant leak down the side of the engine block
Low coolant with no visible hose failure
Coolant smell inside the cab
Milky oil or oil in the coolant
Overheating
Rough running or misfire from a vacuum leak
How to Fix
No recall. Replace the intake manifold gasket set - upper and lower where applicable - using the updated GM gaskets and correct torque sequence; expect roughly $1,000-$1,400 on a Savana 1500/2500 including labor, with the doghouse removal driving most of the cost. Pressure-test the cooling system to confirm the intake gasket rather than a weeping water pump or heater line before committing. If coolant has entered the oil, change oil and filter immediately after the repair and re-check after a short interval. Note that repeat failures years later are reported, so use OE-quality gaskets, not the cheapest set.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Express and GMC Savana vehicles. Incorrect software in the transmission control module (TCM) may result in harsh shifting, reduced power, unintended deceleration, rear wheel lockup, or cause the vehicle to move in an unintended direction.
What is the 2003-2014 GMC Savana Brake Line Corrosion and Brake Fluid Loss (Rust Belt)?
The 2003-2014 GMC Savana uses steel brake lines that are subject to severe corrosion in salt-belt states. The factory lines corrode from the outside in and can rupture without warning, causing catastrophic brake failure. This is the same safety-critical issue as documented across… Repairs typically run $600-$2,000. Severity: high.
What is the 2003-2023 GMC Savana Cutaway Rear HVAC Blower Circuit Corrosion at Left B-Pillar - Fire Risk (Recall 23V-247)?
Savana Cutaway chassis are built with an unused wiring circuit at the lower left B-pillar so that a final-stage upfitter can install an optional rear HVAC blower. When the upfitter leaves that circuit's connectors or cut wire ends unsealed, moisture and road contamination corrode… Repairs typically run $0-$0. Severity: high.
What is the 1996-2014 GMC Savana 4L60E/4L65E Automatic Transmission 3-4 Clutch Pack Burnup and Overdrive Slip (Savana 1500)?
The light-duty Savana 1500 uses the 4L60E (later 4L65E) four-speed, not the heavy-duty 4L80E fitted to 2500/3500 models, and it is the weak link of the lineup. In van duty the converter clutch and overdrive cycle constantly at city speeds, and the 3-4 clutch pack and its apply se… Repairs typically run $1,800-$3,200. Severity: high.
What is the 1996-2014 GMC Savana Ignition Switch Electrical Failure?
The ignition switch (electrical portion, not the lock cylinder) develops worn contacts, causing intermittent no-start, stalling while driving, or loss of electrical accessories. A well-known issue shared with the Chevy Express. Repairs typically run $50-$250. Severity: medium.
What is the 1999-2020 GMC Savana Broken Exhaust Manifold Bolts on Gen III/IV Vortec V8 Causing Cold-Start Tick and Exhaust Leak?
On the 4.8L, 5.3L and 6.0L Vortec V8s the exhaust manifold bolts - almost always the ones at the extreme front and rear of each cylinder head - snap from repeated thermal cycling, letting the manifold lift off the head. The classic symptom is a loud tick or 'exhaust leak' ticking… Repairs typically run $600-$2,200. Severity: medium.
What is the 2010-2020 GMC Savana 6L90 Torque Converter Clutch Friction Wear Causing Driveline Shudder?
When the Savana 2500/3500 moved to the 6L90 six-speed for 2010, a new failure appeared that the old 4L80E did not have. GM's own service information for 2010-2014 Express and Savana vans with the 6.0L flex-fuel V8 and 6L90 acknowledges that torque converter clutch friction materi… Repairs typically run $900-$5,000. Severity: medium.
What is the 1996-2018 GMC Savana Rocker Panel, Lower Door and Wheel Arch Rust-Through?
Savana and Express bodies rot in a predictable pattern: rocker panels beneath the front and sliding doors, the bottoms of the doors themselves, the lower rear quarters at the wheel arches, and the lower skins of the side cargo and rear doors. The doors rust from the inside out -… Repairs typically run $400-$5,000. Severity: medium.
What is the 1996-2014 GMC Savana Intake Manifold Gasket Coolant and Oil Leak on Vortec V8?
Savana V8s develop intake manifold gasket leaks that show up either as an external drip - usually coolant down the driver's side of the block, or oil at the rear of the valley - or, worse, as an internal leak that lets coolant into the oil. Owners of 6.0L vans report antifreeze a… Repairs typically run $1,000-$1,400. Severity: medium.
What is the 1996-2025 GMC Savana Rear Cargo Door and Side Door Hinge Wear?
The rear cargo doors and sliding side door hinges wear out from the weight of the doors and constant commercial use. Doors sag, become difficult to close, and the weatherstripping no longer seals properly. Repairs typically run $100-$400. Severity: low.
