What is the 2003-2014 GMC Savana Brake Line Corrosion and Brake Fluid Loss (Rust Belt)?

The 2003-2014 GMC Savana uses steel brake lines that are subject to severe corrosion in salt-belt states. The factory lines corrode from the outside in and can rupture without warning, causing catastrophic brake failure. This is the same safety-critical issue as documented across… Repairs typically run $600-$2,000. Severity: high.

What is the 1996-2014 GMC Savana Ignition Switch Electrical Failure?

The ignition switch (electrical portion, not the lock cylinder) develops worn contacts, causing intermittent no-start, stalling while driving, or loss of electrical accessories. A well-known issue shared with the Chevy Express. Repairs typically run $50-$250. Severity: medium.

What is the 1999-2020 GMC Savana Broken Exhaust Manifold Bolts on Gen III/IV Vortec V8 Causing Cold-Start Tick and Exhaust Leak?

On the 4.8L, 5.3L and 6.0L Vortec V8s the exhaust manifold bolts - almost always the ones at the extreme front and rear of each cylinder head - snap from repeated thermal cycling, letting the manifold lift off the head. The classic symptom is a loud tick or 'exhaust leak' ticking… Repairs typically run $600-$2,200. Severity: medium.

What is the 2010-2020 GMC Savana 6L90 Torque Converter Clutch Friction Wear Causing Driveline Shudder?

When the Savana 2500/3500 moved to the 6L90 six-speed for 2010, a new failure appeared that the old 4L80E did not have. GM's own service information for 2010-2014 Express and Savana vans with the 6.0L flex-fuel V8 and 6L90 acknowledges that torque converter clutch friction materi… Repairs typically run $900-$5,000. Severity: medium.

What is the 1996-2018 GMC Savana Rocker Panel, Lower Door and Wheel Arch Rust-Through?

Savana and Express bodies rot in a predictable pattern: rocker panels beneath the front and sliding doors, the bottoms of the doors themselves, the lower rear quarters at the wheel arches, and the lower skins of the side cargo and rear doors. The doors rust from the inside out -… Repairs typically run $400-$5,000. Severity: medium.

What is the 1996-2014 GMC Savana Intake Manifold Gasket Coolant and Oil Leak on Vortec V8?

Savana V8s develop intake manifold gasket leaks that show up either as an external drip - usually coolant down the driver's side of the block, or oil at the rear of the valley - or, worse, as an internal leak that lets coolant into the oil. Owners of 6.0L vans report antifreeze a… Repairs typically run $1,000-$1,400. Severity: medium.

What is the 1996-2025 GMC Savana Rear Cargo Door and Side Door Hinge Wear?

The rear cargo doors and sliding side door hinges wear out from the weight of the doors and constant commercial use. Doors sag, become difficult to close, and the weatherstripping no longer seals properly. Repairs typically run $100-$400. Severity: low.

GMC · Known Issues

2014 GMC Savana Problems: 12 Known Issues

2014 model year · 1,120+ owner reports · Updated August 2026

Share:@au7o.io

According to Au7o's analysis of 1,120+ owner reports, the 2014 GMC Savana has 12 documented known issues, with 6 rated critical. The most serious are Fuel Pump Module Failure and Hard Start / Stalling ($350-$900 repair), AFM Lifter Failure on V8 Vortec/EcoTec3 Engines ($3,500-$8,000 repair), Brake Line Corrosion and Brake Fluid Loss (Rust Belt) ($600-$2,000 repair), Cutaway Rear HVAC Blower Circuit Corrosion at Left B-Pillar - Fire Risk (Recall 23V-247) ($0-$0 repair), 4L60E/4L65E Automatic Transmission 3-4 Clutch Pack Burnup and Overdrive Slip (Savana 1500) ($1,800-$3,200 repair) and Driver's Door Power Window Switch Liquid Intrusion and Corrosion - Fire Risk (Recall 18V-295) ($0-$0 repair). The most commonly reported issue is Fuel Pump Module Failure and Hard Start / Stalling with 430 owner reports. Across all issues with published estimates, repair costs range from $50 to $8,000. DIY maintenance guides at au7o.io.

Frequently Asked Questions

What are the most common GMC Savana problems?

According to Au7o's analysis of 1,120+ owner reports, the 2014 GMC Savana has 12 documented issues. The most frequently reported are: Fuel Pump Module Failure and Hard Start / Stalling, AFM Lifter Failure on V8 Vortec/EcoTec3 Engines, Brake Line Corrosion and Brake Fluid Loss (Rust Belt). Of these, 6 are rated critical and should be addressed promptly.

Is the GMC Savana reliable?

The 2014 GMC Savana has 12 known issues documented across 1,120+ owner reports. 6 issues are rated critical: Fuel Pump Module Failure and Hard Start / Stalling and AFM Lifter Failure on V8 Vortec/EcoTec3 Engines and Brake Line Corrosion and Brake Fluid Loss (Rust Belt) and Cutaway Rear HVAC Blower Circuit Corrosion at Left B-Pillar - Fire Risk (Recall 23V-247) and 4L60E/4L65E Automatic Transmission 3-4 Clutch Pack Burnup and Overdrive Slip (Savana 1500) and Driver's Door Power Window Switch Liquid Intrusion and Corrosion - Fire Risk (Recall 18V-295). Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common GMC Savana problems?

Repair costs for known GMC Savana issues range from $0 to $8,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Fuel Pump Module Failure and Hard Start / Stalling, typically costs $350-$900 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 2003-2020 GMC Savana Fuel Pump Module Failure and Hard Start / Stalling?

The GMC Savana (and Chevrolet Express) fuel pump module is known for premature failure between 80,000-140,000 miles, often stranding drivers without warning. The in-tank electric fuel pump motor burns out or the sending unit becomes erratic. Running the tank consistently below 1/… Repairs typically run $350-$900. Severity: high.

All 12 Known Issues

Other GMC Models

Frequently Asked Questions

What are the most common GMC Savana problems?

Is the GMC Savana reliable?

How much does it cost to fix common GMC Savana problems?

What is the 2003-2020 GMC Savana Fuel Pump Module Failure and Hard Start / Stalling?

What is the 2010-2025 GMC Savana AFM Lifter Failure on V8 Vortec/EcoTec3 Engines?

2003-2023 GMC Savana: Cutaway Rear HVAC Blower Circuit Corrosion at Left B-Pillar - Fire Risk (Recall 23V-247)#

2014-2017 GMC Savana: Driver's Door Power Window Switch Liquid Intrusion and Corrosion - Fire Risk (Recall 18V-295)#

1996-2014 GMC Savana: Ignition Switch Electrical Failure#

1996-2014 GMC Savana: 4L60E/4L65E Automatic Transmission 3-4 Clutch Pack Burnup and Overdrive Slip (Savana 1500)#

2010-2020 GMC Savana: 6L90 Torque Converter Clutch Friction Wear Causing Driveline Shudder#

2003-2020 GMC Savana: Fuel Pump Module Failure and Hard Start / Stalling#

2010-2025 GMC Savana: AFM Lifter Failure on V8 Vortec/EcoTec3 Engines#

2003-2014 GMC Savana: Brake Line Corrosion and Brake Fluid Loss (Rust Belt)#

1996-2018 GMC Savana: Rocker Panel, Lower Door and Wheel Arch Rust-Through#

1996-2025 GMC Savana: Rear Cargo Door and Side Door Hinge Wear#

1999-2020 GMC Savana: Broken Exhaust Manifold Bolts on Gen III/IV Vortec V8 Causing Cold-Start Tick and Exhaust Leak#

1996-2014 GMC Savana: Intake Manifold Gasket Coolant and Oil Leak on Vortec V8#