What are the most common Toyota Tundra problems?
According to Au7o's analysis of 127,500+ owner reports, the 2007-2007 Toyota Tundra has 7 documented issues. The most frequently reported are: Frame Rust and Corrosion, Front Lower Ball Joint Failure, Power Steering Gear Assembly Oil Leak. Of these, 3 are rated critical and should be addressed promptly.
Is the Toyota Tundra reliable?
The 2007-2007 Toyota Tundra has 7 known issues documented across 127,500+ owner reports. 3 issues are rated critical: Frame Rust and Corrosion and Front Lower Ball Joint Failure and Power Steering Gear Assembly Oil Leak. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
How much does it cost to fix common Toyota Tundra problems?
Repair costs for known Toyota Tundra issues range from $0 to $15,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Frame Rust and Corrosion, typically costs $500-$15,000 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
What is the 2000-2008 Toyota Tundra Frame Rust and Corrosion?
Toyota Tundra trucks from 2000-2008 are affected by a widespread frame rust issue, particularly in regions where corrosive road salt is used. The frames develop excessive rust on the rear cross member. This can lead to spare tire separation, compromised brake lines, and damage to… Repairs typically run $500-$15,000. Severity: high.
What is the 2004-2007 Toyota Tundra Front Lower Ball Joint Failure?
Toyota issued multiple safety recalls (Recall 50J and 70B) for front suspension lower ball joint issues affecting approximately 533,000 Tundra vehicles. A manufacturing defect caused the ball surface to be scratched, leading to excessive wear and looseness. In extreme cases, the… Repairs typically run $0-$1,600. Severity: high.
What is the 2007-2021 Toyota Tundra Power Steering Gear Assembly Oil Leak?
Toyota recalled 2007-2021 Tundra vehicles due to defects in the power steering gear assembly that can cause oil leaks. When power steering fluid leaks from the assembly, it can result in sudden loss of power steering assist while driving. Repairs typically run $0-$1,500. Severity: high.
What is the 2007-2021 Toyota Tundra Cam Tower Oil Leak?
The 5.7L iForce V8 engine is known for developing oil leaks at the cam tower due to Toyota's use of gray RTV silicone sealant instead of a proper gasket from the factory. The sealant degrades over time, particularly at the rear of the cam towers where the engine is slanted. Repairs typically run $2,500-$4,000. Severity: medium.
What is the 2005-2013 Toyota Tundra Secondary Air Injection Pump Failure?
The secondary air injection pump is prone to failure due to water intrusion. The electric motor is located in the wheel well with moisture exposure, and the rubber boot covering the motor traps water, causing the pump to short circuit. This triggers check engine lights with codes… Repairs typically run $1,500-$4,000. Severity: medium.
What is the 2007-2019 Toyota Tundra Exhaust Manifold Cracking and Bolt Failure?
Toyota Tundra V8 engines are prone to exhaust manifold cracking, particularly on the driver side where the air injection tube weld enters the manifold. Additionally, exhaust manifold bolts can corrode and break, causing exhaust leaks. The ticking noise is most noticeable at cold… Repairs typically run $500-$3,000. Severity: medium.
What is the 2007-2012 Toyota Tundra Water Pump Bearing and Seal Failure?
The 5.7L V8 water pump is prone to premature failure, often occurring between 40,000-70,000 miles. The water pump uses a spring-loaded seal that can fail, and internal bearing failure is common. If not addressed, this can lead to engine overheating and severe damage. Repairs typically run $400-$800. Severity: medium.
