What is the 1990-1995 Chrysler LeBaron 2.5L and 3.0L Head Gasket Failure?

The LeBaron's 2.5L 4-cylinder and 3.0L Mitsubishi V6 engines both suffer from head gasket failure. The 2.5L uses a composite head gasket that deteriorates, allowing coolant into the combustion chambers and oil passages. The 3.0L Mitsubishi V6 develops gasket failure between cylin… Repairs typically run $600-$1,500. Severity: high.

What is the 1985-1995 Chrysler LeBaron Auto Shutdown (ASD) Relay Failure — Cranks but Won't Start (No Spark/No Fuel)?

The Auto Shutdown (ASD) relay powers the ignition coil, fuel injectors, and (via the fuel-pump relay) the fuel pump. When the ASD relay fails, contacts wear, or its connector corrodes, the engine cranks but gets no spark and no fuel and will not start; failure can also be intermi… Repairs typically run $30-$150. Severity: high.

What is the 1990-1995 Chrysler LeBaron A604 (41TE) Ultradrive Limp Mode, Torque-Converter & Clutch Failure?

Beyond the solenoid pack, the A604 (41TE) Ultradrive on V6/turbo LeBarons is infamous for dropping into limp mode — the transmission loses the higher gears and is stuck in second and reverse only, often after a speed/input sensor fault, voltage glitch, or internal clutch problem. Repairs typically run $150-$2,500. Severity: high.

What is the 1989-1995 Chrysler LeBaron Chronic Overheating — Wrong-Rotation Water Pump (1989+) & Cooling System Neglect?

LeBaron overheating is common and one trap is unique to these cars: in 1989 the 2.2/2.5 switched to a counter-rotating (reverse-rotation) water pump driven off the back side of the timing/accessory belt, whereas 1980–1988 used a clockwise pump. Installing the wrong-rotation pump… Repairs typically run $120-$700. Severity: high.

What is the 1985-1995 Chrysler LeBaron Distributor Hall-Effect Pickup Heat-Soak Failure — Intermittent No-Spark Stall?

The distributor pickup is a three-wire Hall-effect sensor that tells the engine computer the engine is turning so it can fire spark and injectors. These pickups are prone to heat-related, intermittent failure: the car runs fine cold but suddenly stalls once the engine bay heats u… Repairs typically run $80-$350. Severity: high.

What is the 1985-1995 Chrysler LeBaron Engine Controller Failure (Logic/Power Module, SMEC, SBEC) — No-Start / Stalling?

Early LeBarons use a two-box system (separate logic module in the kick panel and power module near the battery); 1988+ cars use the combined SMEC, and later cars the SBEC. The power-module/driver section is a known weak point: heat and vibration crack solder joints and fail the i… Repairs typically run $150-$600. Severity: high.

What is the 1985-1995 Chrysler LeBaron Timing Belt Wear and Breakage (2.2L/2.5L/3.0L) — Stranding No-Start?

All LeBaron engines are belt-driven overhead-cam designs with a rubber timing belt that has a finite service life (roughly 60,000 miles). The Chrysler 2.2L/2.5L four-cylinder engines are non-interference designs, so a snapped or skipped belt leaves the car stranded but does not b… Repairs typically run $250-$750. Severity: high.

What is the 1990-1995 Chrysler LeBaron Convertible Top Hydraulic System and Fabric Deterioration?

The LeBaron convertible's hydraulic top system suffers from cylinder leaks, pump failures, and the fabric top material degradating from UV exposure. The hydraulic cylinders develop internal seal leaks, causing the top to operate slowly or stop mid-cycle. The fabric top material s… Repairs typically run $200-$1,500. Severity: medium.

What is the 1985-1995 Chrysler LeBaron Coolant Temperature Sensor Failure — Hot Stall, Erratic Gauge, Hard Restart?

The two-prong engine coolant temperature (ECT) sensor at the thermostat housing feeds temperature data to the engine computer for fuel mixture and to the cooling-fan and gauge circuits. When it fails or its connector corrodes, the computer mis-fuels the engine: the car runs rough… Repairs typically run $40-$180. Severity: medium.

What is the 1985-1995 Chrysler LeBaron Automatic Idle Speed (AIS) Motor Failure — Rough Idle, Stalling, Hunting?

Chrysler's throttle-body and MPI fuel-injection LeBarons use an Automatic Idle Speed (AIS) motor (idle air control) that meters air around the closed throttle to keep the engine idling and to catch the idle when the A/C compressor cycles or when the throttle snaps shut. The AIS p… Repairs typically run $60-$250. Severity: medium.

What is the 1990-1995 Chrysler LeBaron Fuel Injector Clogging and Leaking?

Fuel injectors develop clogs and O-ring leaks from age and fuel deposit buildup. Clogged injectors cause misfires and poor fuel economy. Leaking injector O-rings create a fire hazard from fuel dripping onto the hot engine. Repairs typically run $100-$400. Severity: medium.

What is the 1990-1995 Chrysler LeBaron Mitsubishi 3.0L V6 Valve Stem Seal / Valve Guide Wear — Oil Consumption and Blue Smoke on Startup?

The Mitsubishi-sourced 3.0L V6 is well known for oil consumption caused by hardening valve stem seals and, at higher mileage, worn valve guides. As the seals shrink/harden, oil seeps past the valve stems while the car sits, then burns off on startup as a puff of blue-gray smoke t… Repairs typically run $400-$1,500. Severity: medium.

What is the 1990-1995 Chrysler LeBaron Power Window Motor Failure?

Power window motors fail from worn brushes and aged wiring. The driver side window sees the most use and fails first. Corroded connectors in the door jamb harness can also cause intermittent window operation. Repairs typically run $80-$250. Severity: low.

What is the 1985-1995 Chrysler LeBaron HVAC Blower Motor Resistor Failure — Fan Works Only on High?

The heater/AC blower resistor block that controls the lower fan speeds is a common failure on these cars. When it burns out, the low and medium fan settings stop working and the blower runs only on High (which bypasses the resistor). The resistor typically overheats and fails bec… Repairs typically run $40-$250. Severity: low.

What is the 1990-1995 Chrysler LeBaron Instrument Cluster / Speedometer & Odometer Failure?

LeBaron instrument clusters (both standard and the digital dash) are a common failure point. The speedometer reads zero or erratically and the odometer stops counting, usually from a failed vehicle speed sensor (VSS) on the transaxle, a stripped odometer drive gear / worn speedom… Repairs typically run $60-$350. Severity: low.

Chrysler · Known Issues

1993 Chrysler LeBaron Problems: 16 Known Issues

1993 model year · 515+ owner reports · Updated August 2026

Share:@au7o.io

According to Au7o's analysis of 515+ owner reports, the 1993 Chrysler LeBaron has 16 documented known issues, with 8 rated critical. The most serious are A604 (41TE) Automatic Transaxle Electronic Shift Solenoid Failure ($200-$1,500 repair), 2.5L and 3.0L Head Gasket Failure ($600-$1,500 repair), Auto Shutdown (ASD) Relay Failure — Cranks but Won't Start (No Spark/No Fuel) ($30-$150 repair), A604 (41TE) Ultradrive Limp Mode, Torque-Converter & Clutch Failure ($150-$2,500 repair), Chronic Overheating — Wrong-Rotation Water Pump (1989+) & Cooling System Neglect ($120-$700 repair), Distributor Hall-Effect Pickup Heat-Soak Failure — Intermittent No-Spark Stall ($80-$350 repair), Engine Controller Failure (Logic/Power Module, SMEC, SBEC) — No-Start / Stalling ($150-$600 repair) and Timing Belt Wear and Breakage (2.2L/2.5L/3.0L) — Stranding No-Start.

Frequently Asked Questions

What are the most common Chrysler LeBaron problems?

According to Au7o's analysis of 515+ owner reports, the 1993 Chrysler LeBaron has 16 documented issues. The most frequently reported are: A604 (41TE) Automatic Transaxle Electronic Shift Solenoid Failure, 2.5L and 3.0L Head Gasket Failure, Auto Shutdown (ASD) Relay Failure — Cranks but Won't Start (No Spark/No Fuel). Of these, 8 are rated critical and should be addressed promptly.

Is the Chrysler LeBaron reliable?

The 1993 Chrysler LeBaron has 16 known issues documented across 515+ owner reports. 8 issues are rated critical: A604 (41TE) Automatic Transaxle Electronic Shift Solenoid Failure and 2.5L and 3.0L Head Gasket Failure and Auto Shutdown (ASD) Relay Failure — Cranks but Won't Start (No Spark/No Fuel) and A604 (41TE) Ultradrive Limp Mode, Torque-Converter & Clutch Failure and Chronic Overheating — Wrong-Rotation Water Pump (1989+) & Cooling System Neglect and Distributor Hall-Effect Pickup Heat-Soak Failure — Intermittent No-Spark Stall and Engine Controller Failure (Logic/Power Module, SMEC, SBEC) — No-Start / Stalling and Timing Belt Wear and Breakage (2.2L/2.5L/3.0L) — Stranding No-Start. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Chrysler LeBaron problems?

Repair costs for known Chrysler LeBaron issues range from $30 to $2,500, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, A604 (41TE) Automatic Transaxle Electronic Shift Solenoid Failure, typically costs $200-$1,500 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 1990-1995 Chrysler LeBaron A604 (41TE) Automatic Transaxle Electronic Shift Solenoid Failure?

The LeBaron uses the Chrysler A604 (41TE) 4-speed electronically-controlled automatic transaxle. This was one of the first fully electronic automatics and its solenoid pack is the primary failure point. The solenoids develop internal leaks and electrical failures, causing erratic… Repairs typically run $200-$1,500. Severity: high.

All 16 Known Issues

Other Chrysler Models

Frequently Asked Questions

What are the most common Chrysler LeBaron problems?

Is the Chrysler LeBaron reliable?

How much does it cost to fix common Chrysler LeBaron problems?

What is the 1990-1995 Chrysler LeBaron A604 (41TE) Automatic Transaxle Electronic Shift Solenoid Failure?

1985-1995 Chrysler LeBaron: Auto Shutdown (ASD) Relay Failure — Cranks but Won't Start (No Spark/No Fuel)#

1985-1995 Chrysler LeBaron: Distributor Hall-Effect Pickup Heat-Soak Failure — Intermittent No-Spark Stall#

1985-1995 Chrysler LeBaron: Engine Controller Failure (Logic/Power Module, SMEC, SBEC) — No-Start / Stalling#

1990-1995 Chrysler LeBaron: Power Window Motor Failure#

1990-1995 Chrysler LeBaron: Instrument Cluster / Speedometer & Odometer Failure#

1990-1995 Chrysler LeBaron: 2.5L and 3.0L Head Gasket Failure#

1985-1995 Chrysler LeBaron: Timing Belt Wear and Breakage (2.2L/2.5L/3.0L) — Stranding No-Start#

1990-1995 Chrysler LeBaron: Mitsubishi 3.0L V6 Valve Stem Seal / Valve Guide Wear — Oil Consumption and Blue Smoke on Startup#

1990-1995 Chrysler LeBaron: A604 (41TE) Automatic Transaxle Electronic Shift Solenoid Failure#

1990-1995 Chrysler LeBaron: A604 (41TE) Ultradrive Limp Mode, Torque-Converter & Clutch Failure#

1989-1995 Chrysler LeBaron: Chronic Overheating — Wrong-Rotation Water Pump (1989+) & Cooling System Neglect#

1985-1995 Chrysler LeBaron: Coolant Temperature Sensor Failure — Hot Stall, Erratic Gauge, Hard Restart#

1985-1995 Chrysler LeBaron: Automatic Idle Speed (AIS) Motor Failure — Rough Idle, Stalling, Hunting#

1990-1995 Chrysler LeBaron: Fuel Injector Clogging and Leaking#

1990-1995 Chrysler LeBaron: Convertible Top Hydraulic System and Fabric Deterioration#

1985-1995 Chrysler LeBaron: HVAC Blower Motor Resistor Failure — Fan Works Only on High#