2014 Ford Transit Connect Problems: 17 Issues Every Owner Should Know

2014 model year · 6,115+ owner reports · Updated April 2026

According to Au7o's analysis of 6,115+ owner reports, the 2014 Ford Transit Connect has 17 documented known issues, with 6 rated critical. The most serious are Side Door Latch Failure - Door May Open While Driving (Recall 16S30) ($0-$0 repair), 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11 ($0-$5,500 repair), Ignition Coil Failure and Misfires (2.5L/1.6L) ($120-$650 repair), Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power) ($140-$900 repair), ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On) ($120-$650 repair) and Electric Power Steering Assist Motor Failure ($600-$1,500 repair). The most commonly reported issue is Side Door Latch Failure - Door May Open While Driving (Recall 16S30) with 4,200 owner reports. Across all issues, repair costs range from $0 to $5,500. DIY maintenance guides at au7o.io.

All 17 Known Issues

Filter:

When Issues Typically Appear

EVAP Purge Valve Stuck Open (Hard Start After Refueling)

30K-120K

Rear Liftgate Latch/Handle Failure (Liftgate Won’t Open)

30K-120K

HVAC Blower Motor Resistor/Control Module Failure (Fan Works Only on High or Not at All)

35K-120K

Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power)

40K-140K

ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On)

40K-140K

A/C Compressor Failure or No-Cool Condition (Refrigerant Leak/Compressor Damage)

40K-130K

Rear Door Wiring Harness Break (Liftgate/Rear Electrical Intermittent)

40K-140K

Rear Suspension Clunking Over Bumps — Stabilizer Bar Links and Bushings

40K-70K

Ignition Coil Failure and Misfires (2.5L/1.6L)

50K-150K

Front Wheel Bearing/Hubs Premature Wear (Growl/Hum Increases With Speed)

50K-140K

Electric Power Steering Assist Motor Failure

60K-100K

Catalytic Converter Efficiency Fault (P0420) on 2.5L Duratec

60K-160K

050K100K150K200K mi

Community Reported

560 owners

On the 2014-2018 Ford Transit Connect 1.6L EcoBoost, the 1.6L EcoBoost engine in 2014-2018 Ford Transit Connect has documented issues with coolant loss, overheating, and in severe cases engine fires. Ford issued Recall 14S11 (NHTSA 14V309) for 2013-2014 models covering coolant leakage from the cylinder head that could contact hot engine components and cause fire. The 1.6L EcoBoost was also susceptible to head gasket failure and internal coolant leaks similar to the 1.5L and 2.0L EcoBoost engines in other Ford models. The engine was discontinued and replaced by the 2.0L EcoBoost in later Transit Connect models. The FordTransitConnectForum documents numerous cases of premature engine failure on 1.6L-equipped vans used in commercial service.

This issue also affects: Citroën C3, Acura TL, Audi A7

Common Symptoms

Coolant loss without visible external leak
Engine overheating warning
White smoke from exhaust
Sweet smell from engine bay
Check engine light
Engine rough running or misfires
Smoke or fire from engine compartment (severe cases)

How to Fix

Check safercar.gov for Recall 14V309/14S11 coverage. Dealers replace coolant hose and associated components under recall. For post-recall coolant issues: cylinder head inspection and replacement of head gasket if internal coolant leak is confirmed. Extended warranty coverage varies - contact Ford Customer Relations. For commercial operators: consider replacing the 1.6L EcoBoost with the 2.5L i-VCT engine from later Transit Connect models if available.

What Owners Are Using

Parts and tips from 560+ owners who fixed this issue

NoteIf you have a 2013-2014 Transit Connect 1.6L EcoBoost, check safercar.gov immediately for recall 14V309 (coolant leak/fire risk). This is a safety recall - free repair at any Ford dealer regardless of mileage or current owner.
TipThe 1.6L EcoBoost was discontinued after 2018 Transit Connect. If you have a pre-2018 model with coolant issues, ask your dealer about extended powertrain coverage. Ford has a history of extended warranty programs for EcoBoost coolant issues across all models.
TipFor Transit Connect commercial operators: the 2.5L i-VCT (non-turbo) engine in later models is far more reliable for high-cycle stop-and-go commercial use than the 1.6L EcoBoost. If purchasing used, prioritize 2.5L models for fleet reliability.
UpgradePremium radiator provides improved cooling capacity (Mishimoto Aluminum Radiator)
View on Amazon
UpgradePre-mixed coolant ready for top-off or full flush (Prestone Extended Life Antifreeze Coolant)
View on Amazon

Typical repair cost:$0 - $5,500

Research This Issue

560+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

High Confidence560 reportsLast reported by owners Jun 2025Reviewed Feb 2026

Community Reported

220 owners

On the 2014-2021 Ford Transit Connect, transit Connect owners report intermittent misfires, rough running, and flashing MIL events commonly traced to failing coil-on-plug ignition coils. Heat and age-related breakdown can cause single-cylinder misfires that may damage the catalytic converter if driven long-term. This is frequently documented in owner reports and service records for both the 2.5L Duratec and 1.6L EcoBoost variants.

This issue also affects: Citroën C3, Acura TL, Audi Q5

Common Symptoms

Rough idle and hesitation under load
Flashing check engine light during misfire
Loss of power
Poor fuel economy
Sulfur smell or catalyst overheating (if severe)

How to Fix

Scan for misfire counters and DTCs, then replace the failed ignition coil(s); replace spark plugs if worn or oil-fouled. If multiple coils show weakness, consider replacing the full set and verify no coolant/oil intrusion into plug wells.

Typical repair cost:$120 - $650

Research This Issue

220+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence220 reportsLast reported by owners Invalid DateReviewed Apr 2026

Community Reported

130 owners

On the 2014-2021 Ford Transit Connect, owners report sudden reduced power, poor throttle response, and limp-home behavior due to electronic throttle body contamination/wear or throttle actuator control faults. The issue can be intermittent and may clear after a key cycle, then recur, which is a common pattern in NHTSA complaints and owner reports. It often sets throttle/ETC-related DTCs and can be triggered by carbon buildup or failing throttle position sensing.

This issue also affects: Ford Explorer, Ford Freestyle, Ford Transit

Common Symptoms

Reduced engine power message/limp mode
Poor throttle response or no acceleration
Stalling or near-stalling at idle
Intermittent issue resolved by key cycle
Check engine light on

How to Fix

Confirm DTCs and perform throttle body inspection/cleaning if contamination is present; if faults persist, replace the throttle body assembly and perform the required idle/throttle relearn procedure. Inspect related wiring/connectors and verify PCM updates if applicable.

Typical repair cost:$140 - $900

Research This Issue

130+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence130 reportsLast reported by owners Invalid DateReviewed Apr 2026

Community Reported

4,200 owners

On the 2014-2016 Ford Transit Connect, the 2014-2016 Ford Transit Connect was included in one of Ford's largest-ever recalls affecting over 2 million vehicles for defective side door latches. NHTSA Campaign Number 16V643 covers approximately 112,225 Transit Connect vehicles manufactured between August 9, 2013 and February 1, 2016. The C1A door latch contains a pawl spring tab that is susceptible to cracking and fracture after repeated exposure to high temperatures and normal cycling. A broken spring tab may prevent the door from latching securely or cause a latched door to unlatch while driving. Consumer Reports reported on the massive Ford and Lincoln recall to fix door latches, and NHTSA documented the safety risk of doors opening while the vehicle is in motion. Ford also issued recall 20S30 and 23S36 for additional door latch concerns on overlapping model years.

Common Symptoms

Door does not latch securely when closed
Door ajar warning light stays on
Door opens unexpectedly while driving
Door requires extra force to close properly
Clicking or unusual noise from door latch mechanism
Interior dome light stays on indicating door is ajar

How to Fix

This is a safety recall - repairs are FREE at any Ford dealer regardless of mileage, ownership status, or warranty coverage. Contact Ford at 1-866-436-7332 or check safercar.gov with your VIN. Ford recall numbers: 16S30, 20S30, 23S36. NHTSA campaign numbers: 16V643, additional campaigns may apply. Dealers replace all affected door latches with improved design parts. If you purchased the vehicle used, the recall still applies - check immediately.

What Owners Are Using

Parts and tips from 4,200+ owners who fixed this issue

NoteThis is a SAFETY RECALL - door could open while driving. Check safercar.gov with your VIN immediately. Repair is FREE at any Ford dealer regardless of mileage or whether you are the original owner. If you have a 2014-2016 Transit Connect, do not delay getting this recall performed.
TipFord has issued multiple overlapping door latch recalls (16S30, 20S30, 23S36). Even if one recall was completed on your Transit Connect, check if additional recall campaigns apply. Some vehicles need multiple latch replacements across different recall numbers.
TipCheck NHTSA.gov for active recalls — repairs are performed free at authorized dealers

Typical repair cost:$0 - $0

Research This Issue

4,200+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence4,200 reportsLast reported by owners Feb 2026Reviewed Feb 2026

Community Reported

85 owners

On the 2014-2021 Ford Transit Connect, transit Connect owners report intermittent ABS and traction control warnings caused by wheel speed sensor signal dropouts, often due to sensor contamination, corrosion at connectors, or damaged wiring near the hubs. The issue can be intermittent and may also disable stability control functions until repaired. This pattern appears in NHTSA complaints and owner reports describing ABS/AdvanceTrac warnings and sensor replacement.

This issue also affects: Chrysler 300, GMC Sierra 1500, GMC Yukon XL

Common Symptoms

ABS warning light illuminated
Traction control/AdvanceTrac warning
ABS activates unexpectedly at low speed (sometimes)
Speedometer fluctuation (rare)
Stored wheel speed sensor DTCs

How to Fix

Scan ABS module for wheel speed sensor DTCs and view live wheel speed data to identify the affected corner. Clean/inspect tone rings (if applicable), repair wiring/connectors, or replace the wheel speed sensor; clear codes and verify on a road test.

Typical repair cost:$120 - $650

Research This Issue

85+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence85 reportsLast reported by owners Invalid DateReviewed Apr 2026

On the 2014-2020 Ford Transit Connect, the Transit Connect uses an electric power steering (EPAS) system with a column-mounted assist motor that is prone to failure between 60,000-100,000 miles. Symptoms range from intermittent loss of power assist to complete failure requiring significant steering effort. The steering warning light illuminates and the system may enter a reduced-assist mode. Failures are more common in vehicles used for delivery routes with frequent low-speed turning.

This issue also affects: Fiat 500, Chevrolet Malibu, Chevrolet Uplander

Common Symptoms

Power steering warning light on dashboard
Intermittent heavy steering, especially at low speeds
Complete loss of power steering assist
Steering assist cuts in and out randomly
Whining or grinding noise from steering column area

How to Fix

Replace the electric power steering motor/torque sensor assembly. Ford part DT1Z-3504-C covers most model years. The steering column does not need removal in most cases — the motor unbolt from the column. After replacement, a steering angle sensor calibration must be performed with a Ford IDS or compatible scan tool. Used/remanufactured EPAS motors from reputable rebuilders can save 40-60% over new OEM.

What Owners Are Using

Parts and tips from 0+ owners who fixed this issue

NoteDo NOT ignore an intermittent EPAS warning. Complete failure can happen suddenly while driving, and at low speeds (parking, delivery stops) you need significant upper body strength to steer without assist. This is a safety issue — fix it promptly.
UpgradeCardone remanufactured power steering pump — OE-spec (Cardone Power Steering Pump)
View on Amazon
UpgradePrestone power steering fluid — compatible with most systems (Prestone Power Steering Fluid)
View on Amazon

Typical repair cost:$600 - $1,500

Research This Issue

0+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

High Confidence0 reportsLast reported by owners Invalid DateReviewed Invalid Date

Community Reported

120 owners

On the 2014-2021 Ford Transit Connect, owners report the rear liftgate handle/latch mechanism binding or failing, leaving the liftgate stuck closed or intermittently not releasing. Complaints commonly describe the exterior handle feeling loose or the latch motor/actuator not responding, sometimes after water intrusion or wear in the latch assembly. This is frequently documented in owner reports and NHTSA complaints for Transit Connect wagons.

Common Symptoms

Liftgate will not open with exterior handle
Intermittent latch release; requires repeated attempts
Handle feels loose or has no resistance
Rear cargo access blocked
Latch works only with key fob or only from inside (if equipped)

How to Fix

Inspect liftgate handle and latch for broken linkage and water intrusion; replace the liftgate latch/actuator assembly and/or exterior handle as needed. Verify wiring at the liftgate harness and confirm latch operation with scan tool output tests if equipped.

Typical repair cost:$180 - $650

Research This Issue

120+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence120 reportsLast reported by owners Invalid DateReviewed Apr 2026

On the 2014-2023 Ford Transit Connect, the second-generation Ford Transit Connect (2014+) suffers from premature failure of the sliding door cable and roller mechanism on both driver and passenger sides. The cable frays or snaps, and the nylon rollers crack or wear flat, causing the door to bind, jump off the track, or refuse to open/close fully. This is especially common in commercial-use vehicles that see 20-50+ door cycles per day.

Common Symptoms

Sliding door sticks or binds when opening/closing
Door jumps off track partially
Grinding or scraping noise when operating door
Door will not latch fully closed
Visible frayed cable near door hinge area

How to Fix

Replace the complete sliding door cable and roller assembly (Ford part 9T1Z-16A506-A or equivalent). Both the upper and lower roller assemblies should be replaced together. Lubricate the track rail with white lithium grease every 6 months for commercial use. Some owners upgrade to aftermarket stainless steel roller kits for improved durability.

What Owners Are Using

Parts and tips from 0+ owners who fixed this issue

TipWhen replacing the sliding door cable, also replace both upper and lower rollers even if they look okay. The nylon develops invisible micro-cracks from UV exposure. A $30 roller failing 3 months later means doing the whole job again.
UpgradeTrim removal tool set for body panel work without damage (MICTUNING Trim Removal Tool Set)
View on Amazon
UpgradeBondo body filler for dent and panel repair (Bondo Body Filler Kit)
View on Amazon

Typical repair cost:$350 - $900

Research This Issue

0+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

High Confidence0 reportsLast reported by owners Invalid DateReviewed Invalid Date

On the 2014-2021 Ford Transit Connect, the Transit Connect taillight housing gaskets deteriorate and allow water intrusion into the rear cargo area, particularly on the passenger side. Water pools in the spare tire well and behind interior panels, causing mold, corrosion of wiring harnesses, and eventual electrical gremlins including inoperative taillights and backup camera failures. The issue is worsened by car wash pressure or heavy rain.

Common Symptoms

Water pooling in spare tire well or rear cargo area
Musty or mold smell from rear of vehicle
Intermittent taillight or backup camera failure
Visible moisture or fogging inside taillight lens
Corrosion on rear wiring connectors

How to Fix

Remove both taillight assemblies and replace the foam gaskets with new Ford OEM gaskets or high-quality butyl tape sealant. Clean all mating surfaces thoroughly before resealing. Inspect and dry out the spare tire well and wiring harness connectors for corrosion. Apply dielectric grease to all electrical connectors in the affected area. Check and clear the rear body drain plugs which often clog with debris.

What Owners Are Using

Parts and tips from 0+ owners who fixed this issue

TipSkip the OEM foam gaskets and use 3M butyl tape (3M 08578) instead. It conforms better to the body panel irregularities and lasts much longer. Apply a continuous bead around the entire perimeter of the taillight opening.
UpgradePOR-15 rust preventive coating stops rust permanently (POR-15 Rust Preventive Coating)
View on Amazon
UpgradeRust-Oleum rust converter spray for treating corroded panels (Rust-Oleum Rust Converter Spray)
View on Amazon

Typical repair cost:$50 - $400

Research This Issue

0+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

High Confidence0 reportsLast reported by owners Invalid DateReviewed Invalid Date

Community Reported

160 owners

On the 2014-2021 Ford Transit Connect, transit Connect owners report the cabin blower losing lower speeds, operating only on high, or stopping entirely due to failure of the blower motor resistor/control module. Heat-related stress and connector resistance can damage the module and/or melt the connector, leading to intermittent operation. This issue is widely documented across Ford platforms and appears in Transit Connect owner reports and service bulletins covering blower control faults.

Common Symptoms

Blower works only on highest speed
No airflow from vents despite HVAC on
Intermittent blower operation
Burning smell from passenger footwell area
Melted blower resistor connector

How to Fix

Replace the blower motor resistor/control module and inspect the blower motor for overcurrent draw; replace the blower motor if it draws excessive current. Repair any heat-damaged connector/pigtail and ensure the cabin air filter is not restricted.

Typical repair cost:$120 - $550

Research This Issue

160+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence160 reportsLast reported by owners Invalid DateReviewed Apr 2026

Community Reported

110 owners

On the 2014-2021 Ford Transit Connect, owners report loss of A/C cooling, compressor noise, or compressor clutch/variable displacement control issues leading to warm air. Some cases involve refrigerant leaks at seals/lines, while others involve compressor internal failure contaminating the system. Transit Connect owner reports and service documentation frequently cite compressor replacement and system flush as the corrective action.

Common Symptoms

A/C blows warm or intermittently cool
Compressor noise (grinding/rattling)
A/C cycles rapidly
Low-side pressure abnormal
Refrigerant oil/dye residue at fittings

How to Fix

Recover and measure refrigerant, leak-test with dye/nitrogen, and repair leaking components (O-rings/lines/condenser as needed). If compressor has failed internally, replace the compressor, receiver/drier (or desiccant), and expansion device as applicable, then flush lines and evacuate/recharge to spec.

Typical repair cost:$250 - $1,800

Research This Issue

110+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence110 reportsLast reported by owners Invalid DateReviewed Apr 2026

Community Reported

95 owners

On the 2014-2021 Ford Transit Connect, transit Connect owners report front hub bearing noise that increases with road speed and changes with steering load, sometimes requiring hub replacement earlier than expected. The vehicle’s duty cycle (commercial use, heavy loads) can accelerate wear, and some reports describe repeated replacements. This issue is commonly documented in owner forums and service histories for Transit Connect vans.

Common Symptoms

Humming/growling noise that rises with speed
Noise changes when turning left/right
Vibration felt in steering wheel (sometimes)
Uneven tire wear (sometimes)
ABS light if sensor integrated and damaged (rare)

How to Fix

Road-test to confirm bearing noise and isolate the affected side; replace the front wheel hub/bearing assembly and torque axle nut to specification. Inspect CV joints and tires for secondary noise sources and verify alignment if uneven tire wear is present.

Typical repair cost:$280 - $850

Research This Issue

95+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence95 reportsLast reported by owners Invalid DateReviewed Apr 2026

On the 2014-2022 Ford Transit Connect, the Transit Connect rear suspension develops a persistent clunking or knocking noise over bumps, particularly noticeable at low speeds in parking lots and over speed bumps. The primary cause is worn rear stabilizer bar end links and bushings, though rear shock absorber upper mounts also fail prematurely. Loaded commercial vehicles that regularly carry cargo accelerate wear significantly. The issue typically presents between 40,000-70,000 miles.

Common Symptoms

Clunking or knocking from rear over bumps
Rattling noise on rough roads
Loose feeling in rear end during turns
Noise worsens with cargo load
Visible play in stabilizer bar links when inspected

How to Fix

Replace rear stabilizer bar end links (both sides) and stabilizer bar bushings as a set. Inspect rear shock absorber upper mounts for cracking or separation — replace shocks if mounts are compromised. Moog K750612 end links and Energy Suspension polyurethane bushings are popular upgrades over OEM rubber. Torque all fasteners to spec: end link nuts to 46 ft-lbs, bushing bracket bolts to 35 ft-lbs.

What Owners Are Using

Parts and tips from 0+ owners who fixed this issue

TipAlways replace sway bar end links in pairs. If one side is worn, the other is close behind. Moog problem-solver links with greaseable ball joints last about twice as long as OEM in commercial service.
UpgradePerformance monotube shocks/struts for sport-tuned suspension (Bilstein B8 Sport Shocks/Struts)
View on Amazon
UpgradeStrut mount and bearing for noise-free strut operation (Moog Strut Mount Assembly)
View on Amazon

Typical repair cost:$150 - $500

Research This Issue

0+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

High Confidence0 reportsLast reported by owners Invalid DateReviewed Invalid Date

Community Reported

170 owners

On the 2014-2021 Ford Transit Connect, owners report extended cranking, rough idle, or stalling shortly after refueling due to an EVAP canister purge valve that sticks open and floods the intake with fuel vapor. This failure mode is documented across Ford applications and appears in Transit Connect owner reports and service literature addressing purge valve performance. The condition often triggers EVAP-related DTCs and can worsen over time.

This issue also affects: Chevrolet HHR, Ford Mustang, Ford Ranger

Common Symptoms

Hard start immediately after refueling
Rough idle or stumble after fill-up
Occasional stall when coming to a stop
Fuel odor near engine bay
Check engine light on

How to Fix

Replace the EVAP canister purge valve/solenoid and inspect EVAP lines for liquid fuel contamination. Clear codes and verify proper purge operation with scan tool commands; advise against topping off the tank to reduce recurrence risk.

Typical repair cost:$120 - $450

Research This Issue

170+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence170 reportsLast reported by owners Invalid DateReviewed Apr 2026

Community Reported

140 owners

On the 2014-2021 Ford Transit Connect 2.5L Duratec, transit Connect models with the 2.5L Duratec commonly generate catalyst efficiency codes, often after repeated misfire events, oil consumption, or exhaust leaks upstream of the catalyst. Owners report a persistent check engine light with no drivability change, or reduced power if the catalyst becomes restricted. NHTSA complaints and owner reports frequently cite P0420 and catalytic converter replacement.

This issue also affects: BMW 5 Series, BMW 6 Series, BMW 7 Series

Common Symptoms

Check engine light on
DTC P0420 stored
Sulfur/rotten egg smell (sometimes)
Reduced power if catalyst is restricted
Failed emissions inspection

How to Fix

Diagnose for exhaust leaks, misfires, and fuel trim issues before replacing parts. If confirmed, replace the catalytic converter assembly and address root causes (spark plugs/coils, upstream O2 sensor issues, or oil consumption) to prevent repeat failure.

Typical repair cost:$450 - $2,200

Research This Issue

140+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence140 reportsLast reported by owners Invalid DateReviewed Apr 2026

Community Reported

90 owners

On the 2014-2021 Ford Transit Connect, repeated opening/closing of the liftgate can fatigue and break wires in the rubber boot/harness at the rear hinge area. Owners report intermittent rear wiper, rear defrost, license plate lamps, rear camera, and/or liftgate release issues that come and go with liftgate movement. This pattern is documented in owner reports and NHTSA complaints describing intermittent rear electrical faults tied to harness flexing.

Common Symptoms

Rear wiper inoperative or intermittent
Backup camera cuts out intermittently
License plate lamps flicker or fail
Liftgate release works only sometimes
Problems change when liftgate is moved

How to Fix

Pull back the hinge/boot and perform a continuity test on suspect circuits; repair broken conductors with solder/heat-shrink or replace the rear liftgate harness section. Secure routing to reduce strain and verify all rear functions after repair.

Typical repair cost:$120 - $900

Research This Issue

90+ owners have reported this issue

Google Reddit YouTube NHTSA

Community Reported

Medium Confidence90 reportsLast reported by owners Invalid DateReviewed Apr 2026

Frequently Asked Questions

What are the most common Ford Transit Connect problems?

According to Au7o's analysis of 6,115+ owner reports, the 2014-2014 Ford Transit Connect has 17 documented issues. The most frequently reported are: Side Door Latch Failure - Door May Open While Driving (Recall 16S30), 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11, Ignition Coil Failure and Misfires (2.5L/1.6L). Of these, 6 are rated critical and should be addressed promptly.

Is the Ford Transit Connect reliable?

The 2014-2014 Ford Transit Connect has 17 known issues documented across 6,115+ owner reports. 6 issues are rated critical: Side Door Latch Failure - Door May Open While Driving (Recall 16S30) and 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11 and Ignition Coil Failure and Misfires (2.5L/1.6L) and Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power) and ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On) and Electric Power Steering Assist Motor Failure. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Ford Transit Connect problems?

Repair costs for known Ford Transit Connect issues range from $0 to $5,500, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Side Door Latch Failure - Door May Open While Driving (Recall 16S30), typically costs $0-$0 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 2014-2019 Ford Transit Connect Brake Vacuum Pump Leak/Failure (Hard Brake Pedal, Reduced Assist)?

Some Transit Connect owners report a hard brake pedal and reduced brake assist due to vacuum pump leakage or failure on engines using a mechanical vacuum pump for brake boost. Oil seepage at the pump and declining vacuum can lead to increased stopping effort, especially at low RP… Repairs typically run $350-$1,200. Severity: critical.

All 17 Known Issues

When Issues Typically Appear

2014-2018 Ford Transit Connect: 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11#

Common Symptoms

How to Fix

What Owners Are Using

Research This Issue

2014-2021 Ford Transit Connect: Ignition Coil Failure and Misfires (2.5L/1.6L)#

Common Symptoms

How to Fix

Research This Issue

2014-2021 Ford Transit Connect: Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power)#

Common Symptoms

How to Fix

Research This Issue

2014-2016 Ford Transit Connect: Side Door Latch Failure - Door May Open While Driving (Recall 16S30)#

Common Symptoms

How to Fix

What Owners Are Using

Research This Issue

2014-2021 Ford Transit Connect: ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On)#

Common Symptoms

How to Fix

Research This Issue

2014-2020 Ford Transit Connect: Electric Power Steering Assist Motor Failure#

Common Symptoms

How to Fix

What Owners Are Using

Research This Issue

2014-2021 Ford Transit Connect: Rear Liftgate Latch/Handle Failure (Liftgate Won’t Open)#

Common Symptoms

How to Fix

Research This Issue

2014-2023 Ford Transit Connect: Sliding Door Cable and Roller Mechanism Failure#

Common Symptoms

How to Fix

What Owners Are Using

Research This Issue

2014-2021 Ford Transit Connect: Water Leak Through Taillight Housing Gasket#

Common Symptoms

How to Fix

What Owners Are Using

Research This Issue

2014-2021 Ford Transit Connect: HVAC Blower Motor Resistor/Control Module Failure (Fan Works Only on High or Not at All)#

Common Symptoms

How to Fix

Research This Issue

2014-2021 Ford Transit Connect: A/C Compressor Failure or No-Cool Condition (Refrigerant Leak/Compressor Damage)#

Common Symptoms

How to Fix

Research This Issue

2014-2021 Ford Transit Connect: Front Wheel Bearing/Hubs Premature Wear (Growl/Hum Increases With Speed)#

Common Symptoms

How to Fix

Research This Issue

2014-2022 Ford Transit Connect: Rear Suspension Clunking Over Bumps — Stabilizer Bar Links and Bushings#

Common Symptoms

How to Fix

What Owners Are Using

Research This Issue

2014-2021 Ford Transit Connect: EVAP Purge Valve Stuck Open (Hard Start After Refueling)#

Common Symptoms

How to Fix

Research This Issue

2014-2021 Ford Transit Connect: Catalytic Converter Efficiency Fault (P0420) on 2.5L Duratec#

Common Symptoms

How to Fix

Research This Issue

2014-2021 Ford Transit Connect: Rear Door Wiring Harness Break (Liftgate/Rear Electrical Intermittent)#

Common Symptoms

How to Fix

Research This Issue

Other Ford Models

Frequently Asked Questions

What are the most common Ford Transit Connect problems?

Is the Ford Transit Connect reliable?

How much does it cost to fix common Ford Transit Connect problems?

What is the 2014-2019 Ford Transit Connect Brake Vacuum Pump Leak/Failure (Hard Brake Pedal, Reduced Assist)?

What is the 2014-2016 Ford Transit Connect Side Door Latch Failure - Door May Open While Driving (Recall 16S30)?

What is the 2014-2018 Ford Transit Connect 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11?