What is the 2014-2018 Ford Transit Connect 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11?

The 1.6L EcoBoost engine in 2014-2018 Ford Transit Connect has documented issues with coolant loss, overheating, and in severe cases engine fires. Ford issued Recall 14S11 (NHTSA 14V309) for 2013-2014 models covering coolant leakage from the cylinder head that could contact hot e… Repairs typically run $0-$5,500. Severity: high.

What is the 2014-2021 Ford Transit Connect Ignition Coil Failure and Misfires (2.5L/1.6L)?

Transit Connect owners report intermittent misfires, rough running, and flashing MIL events commonly traced to failing coil-on-plug ignition coils. Heat and age-related breakdown can cause single-cylinder misfires that may damage the catalytic converter if driven long-term. This… Repairs typically run $120-$650. Severity: high.

What is the 2014-2021 Ford Transit Connect Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power)?

Owners report sudden reduced power, poor throttle response, and limp-home behavior due to electronic throttle body contamination/wear or throttle actuator control faults. The issue can be intermittent and may clear after a key cycle, then recur, which is a common pattern in NHTSA… Repairs typically run $140-$900. Severity: high.

What is the 2014-2021 Ford Transit Connect ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On)?

Transit Connect owners report intermittent ABS and traction control warnings caused by wheel speed sensor signal dropouts, often due to sensor contamination, corrosion at connectors, or damaged wiring near the hubs. The issue can be intermittent and may also disable stability con… Repairs typically run $120-$650. Severity: high.

What is the 2014-2019 Ford Transit Connect Brake Vacuum Pump Leak/Failure (Hard Brake Pedal, Reduced Assist)?

Some Transit Connect owners report a hard brake pedal and reduced brake assist due to vacuum pump leakage or failure on engines using a mechanical vacuum pump for brake boost. Oil seepage at the pump and declining vacuum can lead to increased stopping effort, especially at low RP… Repairs typically run $350-$1,200. Severity: high.

What is the 2014-2015 Ford Transit Connect Fuel Pump Recall 14S30 / NHTSA 15V005 - Stalling Without Warning?

Of all the vehicles pulled into NHTSA recall 15V005000, the Transit Connect has by far the widest build window: 2014 and 2015 vans manufactured November 11, 2013 through August 29, 2014 were added when Ford expanded the campaign on April 30, 2015. The cause is improper nickel pla… Severity: high.

What is the 2014-2020 Ford Transit Connect Electric Power Steering Assist Motor Failure?

The Transit Connect uses an electric power steering (EPAS) system with a column-mounted assist motor that is prone to failure between 60,000-100,000 miles. Symptoms range from intermittent loss of power assist to complete failure requiring significant steering effort. The steerin… Repairs typically run $600-$1,500. Severity: high.

What is the 2014-2021 Ford Transit Connect EVAP Purge Valve Stuck Open (Hard Start After Refueling)?

Owners report extended cranking, rough idle, or stalling shortly after refueling due to an EVAP canister purge valve that sticks open and floods the intake with fuel vapor. This failure mode is documented across Ford applications and appears in Transit Connect owner reports and s… Repairs typically run $120-$450. Severity: medium.

What is the 2014-2021 Ford Transit Connect HVAC Blower Motor Resistor/Control Module Failure (Fan Works Only on High or Not at All)?

Transit Connect owners report the cabin blower losing lower speeds, operating only on high, or stopping entirely due to failure of the blower motor resistor/control module. Heat-related stress and connector resistance can damage the module and/or melt the connector, leading to in… Repairs typically run $120-$550. Severity: medium.

What is the 2014-2021 Ford Transit Connect Catalytic Converter Efficiency Fault (P0420) on 2.5L Duratec?

Transit Connect models with the 2.5L Duratec commonly generate catalyst efficiency codes, often after repeated misfire events, oil consumption, or exhaust leaks upstream of the catalyst. Owners report a persistent check engine light with no drivability change, or reduced power if… Repairs typically run $450-$2,200. Severity: medium.

What is the 2014-2021 Ford Transit Connect Rear Liftgate Latch/Handle Failure (Liftgate Won’t Open)?

Owners report the rear liftgate handle/latch mechanism binding or failing, leaving the liftgate stuck closed or intermittently not releasing. Complaints commonly describe the exterior handle feeling loose or the latch motor/actuator not responding, sometimes after water intrusion… Repairs typically run $180-$650. Severity: medium.

What is the 2014-2021 Ford Transit Connect A/C Compressor Failure or No-Cool Condition (Refrigerant Leak/Compressor Damage)?

Owners report loss of A/C cooling, compressor noise, or compressor clutch/variable displacement control issues leading to warm air. Some cases involve refrigerant leaks at seals/lines, while others involve compressor internal failure contaminating the system. Transit Connect owne… Repairs typically run $250-$1,800. Severity: medium.

What is the 2014-2021 Ford Transit Connect Front Wheel Bearing/Hubs Premature Wear (Growl/Hum Increases With Speed)?

Transit Connect owners report front hub bearing noise that increases with road speed and changes with steering load, sometimes requiring hub replacement earlier than expected. The vehicle’s duty cycle (commercial use, heavy loads) can accelerate wear, and some reports describe re… Repairs typically run $280-$850. Severity: medium.

What is the 2014-2021 Ford Transit Connect Rear Door Wiring Harness Break (Liftgate/Rear Electrical Intermittent)?

Repeated opening/closing of the liftgate can fatigue and break wires in the rubber boot/harness at the rear hinge area. Owners report intermittent rear wiper, rear defrost, license plate lamps, rear camera, and/or liftgate release issues that come and go with liftgate movement. T… Repairs typically run $120-$900. Severity: medium.

What is the 2014-2023 Ford Transit Connect Sliding Door Cable and Roller Mechanism Failure?

The second-generation Ford Transit Connect (2014+) suffers from premature failure of the sliding door cable and roller mechanism on both driver and passenger sides. The cable frays or snaps, and the nylon rollers crack or wear flat, causing the door to bind, jump off the track, o… Repairs typically run $350-$900. Severity: medium.

What is the 2014-2021 Ford Transit Connect Water Leak Through Taillight Housing Gasket?

The Transit Connect taillight housing gaskets deteriorate and allow water intrusion into the rear cargo area, particularly on the passenger side. Water pools in the spare tire well and behind interior panels, causing mold, corrosion of wiring harnesses, and eventual electrical gr… Repairs typically run $50-$400. Severity: medium.

What is the 2014-2022 Ford Transit Connect Rear Suspension Clunking Over Bumps — Stabilizer Bar Links and Bushings?

The Transit Connect rear suspension develops a persistent clunking or knocking noise over bumps, particularly noticeable at low speeds in parking lots and over speed bumps. The primary cause is worn rear stabilizer bar end links and bushings, though rear shock absorber upper moun… Repairs typically run $150-$500. Severity: low.

Ford · Known Issues

2015 Ford Transit Connect Problems: 18 Known Issues

2015 model year · 6,115+ owner reports · Updated September 2026

Share:@au7o.io

According to Au7o's analysis of 6,115+ owner reports, the 2015 Ford Transit Connect has 18 documented known issues, with 8 rated critical. The most serious are Side Door Latch Failure - Door May Open While Driving (Recall 16S30) ($0-$0 repair), 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11 ($0-$5,500 repair), Ignition Coil Failure and Misfires (2.5L/1.6L) ($120-$650 repair), Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power) ($140-$900 repair), ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On) ($120-$650 repair), Brake Vacuum Pump Leak/Failure (Hard Brake Pedal, Reduced Assist) ($350-$1,200 repair), Fuel Pump Recall 14S30 / NHTSA 15V005 - Stalling Without Warning and Electric Power Steering Assist Motor Failure ($600-$1,500 repair).

Frequently Asked Questions

What are the most common Ford Transit Connect problems?

According to Au7o's analysis of 6,115+ owner reports, the 2015 Ford Transit Connect has 18 documented issues. The most frequently reported are: Side Door Latch Failure - Door May Open While Driving (Recall 16S30), 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11, Ignition Coil Failure and Misfires (2.5L/1.6L). Of these, 8 are rated critical and should be addressed promptly.

Is the Ford Transit Connect reliable?

The 2015 Ford Transit Connect has 18 known issues documented across 6,115+ owner reports. 8 issues are rated critical: Side Door Latch Failure - Door May Open While Driving (Recall 16S30) and 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11 and Ignition Coil Failure and Misfires (2.5L/1.6L) and Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power) and ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On) and Brake Vacuum Pump Leak/Failure (Hard Brake Pedal, Reduced Assist) and Fuel Pump Recall 14S30 / NHTSA 15V005 - Stalling Without Warning and Electric Power Steering Assist Motor Failure. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Ford Transit Connect problems?

Repair costs for known Ford Transit Connect issues range from $0 to $5,500, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Side Door Latch Failure - Door May Open While Driving (Recall 16S30), typically costs $0-$0 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 2014-2016 Ford Transit Connect Side Door Latch Failure - Door May Open While Driving (Recall 16S30)?

The 2014-2016 Ford Transit Connect was included in one of Ford's largest-ever recalls affecting over 2 million vehicles for defective side door latches. NHTSA Campaign Number 16V643 covers approximately 112,225 Transit Connect vehicles manufactured between August 9, 2013 and Febr… Repairs typically run $0-$0. Severity: high.

All 18 Known Issues

Other Ford Models

Frequently Asked Questions

What are the most common Ford Transit Connect problems?

Is the Ford Transit Connect reliable?

How much does it cost to fix common Ford Transit Connect problems?

What is the 2014-2016 Ford Transit Connect Side Door Latch Failure - Door May Open While Driving (Recall 16S30)?

When Issues Typically Appear

2014-2018 Ford Transit Connect: 1.6L EcoBoost Engine Overheating and Coolant Loss - Recall 14S11#

2014-2021 Ford Transit Connect: Ignition Coil Failure and Misfires (2.5L/1.6L)#

2014-2021 Ford Transit Connect: Throttle Body/ETC Fault Causing Limp Mode (Reduced Engine Power)#

2014-2016 Ford Transit Connect: Side Door Latch Failure - Door May Open While Driving (Recall 16S30)#

2014-2021 Ford Transit Connect: ABS Wheel Speed Sensor/Wiring Fault (ABS/Traction Control Lights On)#

2014-2015 Ford Transit Connect: Fuel Pump Recall 14S30 / NHTSA 15V005 - Stalling Without Warning#

2014-2021 Ford Transit Connect: EVAP Purge Valve Stuck Open (Hard Start After Refueling)#

2014-2019 Ford Transit Connect: Brake Vacuum Pump Leak/Failure (Hard Brake Pedal, Reduced Assist)#

2014-2020 Ford Transit Connect: Electric Power Steering Assist Motor Failure#

2014-2021 Ford Transit Connect: Rear Liftgate Latch/Handle Failure (Liftgate Won’t Open)#

2014-2023 Ford Transit Connect: Sliding Door Cable and Roller Mechanism Failure#

2014-2021 Ford Transit Connect: Water Leak Through Taillight Housing Gasket#

2014-2021 Ford Transit Connect: HVAC Blower Motor Resistor/Control Module Failure (Fan Works Only on High or Not at All)#

2014-2021 Ford Transit Connect: A/C Compressor Failure or No-Cool Condition (Refrigerant Leak/Compressor Damage)#

2014-2021 Ford Transit Connect: Front Wheel Bearing/Hubs Premature Wear (Growl/Hum Increases With Speed)#

2014-2022 Ford Transit Connect: Rear Suspension Clunking Over Bumps — Stabilizer Bar Links and Bushings#

2014-2021 Ford Transit Connect: Catalytic Converter Efficiency Fault (P0420) on 2.5L Duratec#

2014-2021 Ford Transit Connect: Rear Door Wiring Harness Break (Liftgate/Rear Electrical Intermittent)#