What is the 2021-2023 Jeep Wrangler Wrangler 4xe PHEV high-voltage battery fire risk (recall 23V-787, park outside)?

Wrangler 4xe plug-in hybrids can experience a high-voltage battery pack fire — including while parked and turned off. FCA opened an investigation in May 2023 after field reports of 2021 MY 4xe HV-battery fires; by September 2023 it had at least seven reports of 2021-2022 4xe batt… Repairs typically run $0-$0. Severity: high.

What is the 2021-2025 Jeep Wrangler 4xe Repeated 12V Battery Drain / Complete Electrical Shutdown?

Wrangler 4xe owners report repeated dead 12V auxiliary batteries and, in some cases, complete electrical shutdowns. Several owners found the included Level 1 charger drains the 12V battery after the high-voltage pack reaches 100%, leaving the vehicle unresponsive within days. Bey… Repairs typically run $0-$400. Severity: high.

What is the 2018-2024 Jeep Wrangler Steering Gear Box Loose Play & Highway Wandering (Aluminum-to-Steel Box TSB)?

JL Wranglers (and the related Gladiator) are widely reported to have vague, loose on-center steering that wanders and drifts at highway speed, forcing constant correction. This is distinct from death wobble — it is excessive play and tracking instability in the steering gear itse… Repairs typically run $0-$1,200. Severity: high.

What is the 2018-2024 Jeep Wrangler eTorque Belt-Starter Generator (BSG) / 48V Power Pack Failure — Charging & No-Start?

eTorque (mild-hybrid) Wranglers replace the conventional alternator/starter with a 48V belt-driven motor-generator (BSG/MGU) plus a 48V power pack unit (PPU) and a 12V system. Owners report charging-system failures, battery warning lights, rough/failed auto-starts during stop-sta… Repairs typically run $0-$3,000. Severity: high.

What is the 2018-2023 Jeep Wrangler Manual Transmission Clutch Issues (JL)?

The JL Wrangler with manual transmission can experience clutch issues including premature wear, judder, and difficulty engaging gears. Some owners report clutch failures at relatively low mileage, particularly with off-road or aggressive driving. Repairs typically run $800-$2,500. Severity: medium.

What is the 2007-2024 Jeep Wrangler Electronic Sway Bar Disconnect Failure (Rubicon) — Water Ingress & Corrosion?

Rubicon models use an electronic front sway-bar disconnect actuator (motor + gear + control electronics) so the bar can be uncoupled for off-road articulation. The actuator housing has poor sealing, and water from everyday puddles, rain, or shallow fording (well under the adverti… Repairs typically run $200-$1,800. Severity: medium.

What is the 2018-2025 Jeep Wrangler 2.0L Turbo Coolant Leak from Y-Fitting, Reservoir & Coolant Inlet Tube Fasteners?

The 2.0L turbocharged four-cylinder (GME-T4) is prone to recurring low-coolant warnings and external coolant leaks. Heat radiating off the turbocharger embrittles the plastic coolant 'Y' fitting and the coolant overflow/recovery reservoir, causing them to crack and weep. Separate… Repairs typically run $120-$600. Severity: medium.

What is the 2018-2024 Jeep Wrangler Uconnect 4/5 Touchscreen Freezing, Reboot Loops & Backup Camera Blackout?

The 8.4-inch Uconnect 4 and the newer Uconnect 5 head units frequently freeze, glitch, reboot multiple times before booting, or go to a black screen. A common and safety-relevant failure mode is the rear backup camera failing to display when shifted into Reverse, showing a blue/b… Repairs typically run $0-$1,200. Severity: medium.

What is the 2018-2024 Jeep Wrangler Aluminum Body Panel & Door Hinge Galvanic Corrosion (Paint Bubbling/Flaking)?

JL Wranglers (and related JT Gladiators) built from 2018 on suffer paint bubbling, flaking, and white corrosion most visibly at the door hinges and along aluminum door panels and hood edges. The root cause is galvanic corrosion: the aluminum doors meet steel hinges, and the elect… Repairs typically run $0-$1,500. Severity: medium.

What is the 2012-2025 Jeep Wrangler 3.6L Pentastar Plastic Oil Cooler / Filter Housing Cracking & Oil Leak?

The 3.6L Pentastar's combined oil cooler and oil filter housing adapter sits in the engine valley and is made of plastic that hardens, warps, and cracks under sustained underhood heat — it can also crack from over-tightening the oil filter cap. The resulting oil (and sometimes co… Repairs typically run $150-$700. Severity: medium.

What is the 2007-2023 Jeep Wrangler Hardtop Rear Tempered Glass Spontaneous Shattering?

Owners across JK and JL hardtops report the rear (and occasionally quarter) tempered glass spontaneously exploding into pebbles with no impact — often while parked or driving normally. Tempered glass can fail from manufacturing-induced internal stress (nickel-sulfide inclusions,… Repairs typically run $200-$800. Severity: medium.

What is the 2018-2023 Jeep Wrangler Windshield cracks/chips far too easily (thin, fragile glass)?

JL Wranglers (and Gladiators) are widely reported to have windshields that crack, chip and fracture from minor road debris impacts that would not damage a typical windshield — sometimes within days or a few miles of delivery. The near-vertical windshield and apparently thin glass… Repairs typically run $250-$1,000. Severity: medium.

What is the 2007-2025 Jeep Wrangler Front Wheel Hub/Bearing Assembly Failure (Integrated ABS Sensor) — Grinding & ABS Light?

Front (and sometimes rear) sealed wheel hub/bearing assemblies are a high-wear item on JK and JL Wranglers, especially on lifted rigs running larger tires that load the bearing harder. As the bearing wears it produces a speed-dependent grinding, rumbling, or humming that changes… Repairs typically run $150-$600. Severity: medium.

What is the 2012-2025 Jeep Wrangler 8HP 8-Speed Automatic Harsh/Jerky Shifting and Delayed Engagement?

Wranglers equipped with the ZF-based 8-speed automatic (845RE/850RE/8HP) are widely reported to shift harshly or jerk, especially the 1-2 shift and when accelerating from a stop, plus delayed engagement when moving from Park to Drive or Reverse. Many cases are resolved by a Trans… Repairs typically run $150-$3,500. Severity: medium.

What is the 2018-2023 Jeep Wrangler ESS (Engine Start-Stop) System Issues?

The automatic engine start-stop system can be problematic, with complaints about delayed restarts, aggressive shutoffs, and system deactivating in conditions where owners expect it to work. The system defaults to ON each time the vehicle starts. Repairs typically run $50-$300. Severity: low.

What is the 2018-2023 Jeep Wrangler Hardtop Water Leaks?

The hardtop can leak water into the cabin, particularly around the freedom panels, rear window seals, or the seal where the top meets the body. Water intrusion can wet carpets, seats, and cause electrical issues over time. Repairs typically run $50-$500. Severity: low.

What is the 2018-2023 Jeep Wrangler Hardtop Freedom Panel water leaks onto windshield header / radio?

The two removable 'Freedom Panel' roof sections over the front seats on hardtop JL Wranglers commonly leak water — most often at the front edge near the windshield header and at the center seam between the panels — allowing water to drip onto the headliner, sun visors, dash and e… Repairs typically run $0-$300. Severity: low.

Jeep · Known Issues

2023 Jeep Wrangler Problems: 21 Issues Every Owner Should Know

2023 model year · 1,820+ owner reports · Updated July 2026

Share:@au7o.io

According to Au7o's analysis of 1,820+ owner reports, the 2023 Jeep Wrangler has 21 documented known issues, with 7 rated critical. The most serious are Death Wobble: violent front-end shaking at highway speed (solid front axle) ($150-$1,200 repair), Wrangler 4xe PHEV high-voltage battery fire risk (recall 23V-787, park outside) ($0-$0 repair), Manual transmission clutch pressure plate overheating / fire risk (recall 21V-028 & 23V-116) ($0-$0 repair), Electric-Hydraulic Power Steering Pump Wiring Overheat — Fire Risk & Loss of Assist (2026 Recall) ($0-$0 repair), 4xe Repeated 12V Battery Drain / Complete Electrical Shutdown ($0-$400 repair), Steering Gear Box Loose Play & Highway Wandering (Aluminum-to-Steel Box TSB) ($0-$1,200 repair) and eTorque Belt-Starter Generator (BSG) / 48V Power Pack Failure — Charging & No-Start ($0-$3,000 repair). The most commonly reported issue is with 780 owner reports. at .

Frequently Asked Questions

What are the most common Jeep Wrangler problems?

According to Au7o's analysis of 1,820+ owner reports, the 2023 Jeep Wrangler has 21 documented issues. The most frequently reported are: Death Wobble: violent front-end shaking at highway speed (solid front axle), Wrangler 4xe PHEV high-voltage battery fire risk (recall 23V-787, park outside), Manual transmission clutch pressure plate overheating / fire risk (recall 21V-028 & 23V-116). Of these, 7 are rated critical and should be addressed promptly.

Is the Jeep Wrangler reliable?

The 2023 Jeep Wrangler has 21 known issues documented across 1,820+ owner reports. 7 issues are rated critical: Death Wobble: violent front-end shaking at highway speed (solid front axle) and Wrangler 4xe PHEV high-voltage battery fire risk (recall 23V-787, park outside) and Manual transmission clutch pressure plate overheating / fire risk (recall 21V-028 & 23V-116) and Electric-Hydraulic Power Steering Pump Wiring Overheat — Fire Risk & Loss of Assist (2026 Recall) and 4xe Repeated 12V Battery Drain / Complete Electrical Shutdown and Steering Gear Box Loose Play & Highway Wandering (Aluminum-to-Steel Box TSB) and eTorque Belt-Starter Generator (BSG) / 48V Power Pack Failure — Charging & No-Start. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.

How much does it cost to fix common Jeep Wrangler problems?

Repair costs for known Jeep Wrangler issues range from $0 to $3,500, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, Death Wobble: violent front-end shaking at highway speed (solid front axle), typically costs $150-$1,200 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.

What is the 2012-2023 Jeep Wrangler Death Wobble: violent front-end shaking at highway speed (solid front axle)?

Wranglers (JK and JL) with a solid front axle are prone to 'death wobble' — a violent, self-reinforcing side-to-side oscillation of the front-end steering components and steering wheel, typically triggered by hitting a bump, expansion joint or pothole at speeds above ~45-55 mph. Repairs typically run $150-$1,200. Severity: high.

All 21 Known Issues

Other Jeep Models

Frequently Asked Questions

What are the most common Jeep Wrangler problems?

Is the Jeep Wrangler reliable?

How much does it cost to fix common Jeep Wrangler problems?

What is the 2012-2023 Jeep Wrangler Death Wobble: violent front-end shaking at highway speed (solid front axle)?

2021-2023 Jeep Wrangler: Wrangler 4xe PHEV high-voltage battery fire risk (recall 23V-787, park outside)#

2021-2025 Jeep Wrangler: 4xe Repeated 12V Battery Drain / Complete Electrical Shutdown#

2018-2024 Jeep Wrangler: eTorque Belt-Starter Generator (BSG) / 48V Power Pack Failure — Charging & No-Start#

2018-2024 Jeep Wrangler: Uconnect 4/5 Touchscreen Freezing, Reboot Loops & Backup Camera Blackout#

2018-2023 Jeep Wrangler: ESS (Engine Start-Stop) System Issues#

2012-2023 Jeep Wrangler: Death Wobble: violent front-end shaking at highway speed (solid front axle)#

2021-2025 Jeep Wrangler: Electric-Hydraulic Power Steering Pump Wiring Overheat — Fire Risk & Loss of Assist (2026 Recall)#

2018-2024 Jeep Wrangler: Steering Gear Box Loose Play & Highway Wandering (Aluminum-to-Steel Box TSB)#

2018-2023 Jeep Wrangler: Manual transmission clutch pressure plate overheating / fire risk (recall 21V-028 & 23V-116)#

2018-2023 Jeep Wrangler: Manual Transmission Clutch Issues (JL)#

2012-2025 Jeep Wrangler: 8HP 8-Speed Automatic Harsh/Jerky Shifting and Delayed Engagement#

2018-2024 Jeep Wrangler: Aluminum Body Panel & Door Hinge Galvanic Corrosion (Paint Bubbling/Flaking)#

2018-2023 Jeep Wrangler: Windshield cracks/chips far too easily (thin, fragile glass)#

2018-2023 Jeep Wrangler: Hardtop Water Leaks#

2018-2023 Jeep Wrangler: Hardtop Freedom Panel water leaks onto windshield header / radio#

2007-2024 Jeep Wrangler: Electronic Sway Bar Disconnect Failure (Rubicon) — Water Ingress & Corrosion#

2007-2025 Jeep Wrangler: Front Wheel Hub/Bearing Assembly Failure (Integrated ABS Sensor) — Grinding & ABS Light#

2007-2023 Jeep Wrangler: Hardtop Rear Tempered Glass Spontaneous Shattering#

2007-2025 Jeep Wrangler: Soft Top Header Warp, Wind Noise, Leaks & Zipper Failure#

2018-2025 Jeep Wrangler: 2.0L Turbo Coolant Leak from Y-Fitting, Reservoir & Coolant Inlet Tube Fasteners#

2012-2025 Jeep Wrangler: 3.6L Pentastar Plastic Oil Cooler / Filter Housing Cracking & Oil Leak#